Recalls apply to specific production ranges. To see whether a particular car still has an open recall, enter its VIN at nhtsa.gov/recalls. Repairs for safety recalls are free at authorised dealers.
2019 BMW 330I recalls
Electrical system: starter assembly, relay
NHTSA campaign 25V636000 · reported September 23, 2025 · BMW of North America, LLC · 199,674 vehicles potentially affected
- The problem
- BMW of North America, LLC (BMW) is recalling certain 2019-2021 BMW 330i, 2019-2022 BMW Z4, 2020-2022 BMW 530i, X3, X4, Toyota Supra, 2021-2022 BMW 430i, 430i Convertible, and 2022 BMW 230i vehicles. The engine starter relay may corrode, causing the relay to overheat and short circuit.
- The risk
- A short circuit in the starter relay may increase the risk of a fire.
- The fix
- Owners are advised to park their vehicles outside and away from structures until the remedy is complete. Dealers will replace the engine starter, free of charge. Owner notification letters were mailed February 6, 2026. Owners may contact BMW customer service at 1-800-525-7417. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov November 14, 2025.
Electrical system: software · Seat belts
NHTSA campaign 23V584000 · reported August 16, 2023 · BMW of North America, LLC · 144 vehicles potentially affected
- The problem
- BMW of North America, LLC (BMW) is recalling certain 2019-2022 330i, 330i xDrive, M340i, 2022 430i Coupe, 2021-2022 430i, M440i Convertible, and 2020-2022 228i xDrive Gran Coupe vehicles. The receiver audio module control unit software may fail to properly generate audible seat belt warnings to the driver to fasten their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
- The risk
- An audible chime that does not properly alert the driver to fasten their seat belt increases the risk of injury in a crash.
- The fix
- Dealers will update the receiver audio module software, free of charge. Owner notification letters were mailed October 12, 2023. Owners may contact BMW customer service at 1-800-525-7417.
Seats
NHTSA campaign 23V211000 · reported March 29, 2023 · BMW of North America, LLC · 51 vehicles potentially affected
- The problem
- BMW of North America, LLC (BMW) is recalling certain 2019-2021 330i, 330i xDrive, M340i xDrive, 2020-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, 2021 X3 xDrive30e, X4 xDrive30i, and X4M vehicles. The seat frame may not have been welded properly to the seat rails.
- The risk
- An improperly welded seat frame may not properly restrain the occupant during a crash, increasing the risk of injury.
- The fix
- Dealers will replace the seat frame and back rest, free of charge. Owner notification letters were mailed May 22, 2023. Owners may contact BMW customer service at 1-800-525-7417.
Back over prevention: software · Back over prevention: sensing system, camera
NHTSA campaign 21V096000 · reported February 19, 2021 · BMW of North America, LLC · 13,858 vehicles potentially affected
- The problem
- BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i xDrive, M8, 2020-2021 530e, 530e xDrive, 330e, 330e xDrive, 745Le, 745Le xDrive, X5 xDrive45e, X3 xDrive30e, X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6 M50i, X6M, 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 740i, 740Li, 740Li xDrive, M760i Drive, M760Li xDrive, 750Li xDrive Alpina, Alpina B7 xDrive, and 2021 4 Series Coupe 430i, 430i xDrive, M440i xDrive vehicles. When shifting into Reverse, a small portion of the rearview image may be obscured, or the screen may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
- The risk
- If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.
- The fix
- BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Steering: linkages, tie rod assembly
NHTSA campaign 20V355000 · reported June 15, 2020 · BMW of North America, LLC · 2,779 vehicles potentially affected
- The problem
- BMW of North America, LLC (BMW) is recalling certain 2019 Z4 sDrive30i, 2019-2020 330i xDrive, M340i and M340i xDrive, 2020 X3M and X4M, and Toyota Supra vehicles. In certain driving conditions, such as high temperatures and rough road surfaces, a steering gear tie rod may become damaged, possibly resulting in a fractured tie rod.
- The risk
- A damaged or fractured tie rod may affect vehicle handling and control, increasing the risk of a crash.
- The fix
- BMW and Toyota will notify owners, and dealers will replace the steering gear tie rods, free of charge. The recall began August 14, 2020. Owners may contact BMW customer service at 1-800-525-7417 or Toyota customer service at 1-888-270-9371.
Seat belts: pretensioner
NHTSA campaign 19V912000 · reported December 20, 2019 · BMW of North America, LLC · 135 vehicles potentially affected
- The problem
- BMW of North America, LLC (BMW) is recalling certain 2019-2020 330i and 330i xDrive vehicles. The outboard rear seat belt pretensioners may not lock as intended during a crash.
- The risk
- In the event of a crash, if the seat belt pretensioners fail to lock, there is an increased risk of injury.
- The fix
- BMW will notify owners, and dealers will replace the rear seat belts, free of charge. The recall is expected to begin February 10, 2020. Owners may contact BMW customer at 1-800-525-7417.
Engine
NHTSA campaign 19V732000 · reported October 15, 2019 · BMW of North America, LLC · 217 vehicles potentially affected
- The problem
- BMW of North America, LLC (BMW) is recalling certain 2019-2020 330i, 330i xDrive, and 2019 Z4 vehicles. The needle roller bearings of the counterbalance shafts may have been improperly installed, potentially causing the counterbalance shaft to loosen.
- The risk
- If the counterbalance shaft loosens, severe engine damage could occur, increasing the risk of a crash.
- The fix
- BMW will notify owners, and dealers will replace the engine, free of charge. The recall began December 13, 2019. Owners may contact BMW customer service at 1-800-525-7417.
Back over prevention: sensing system, camera
NHTSA campaign 19V684000 · reported September 27, 2019 · BMW of North America, LLC · 257,473 vehicles potentially affected
- The problem
- BMW of North America, LLC (BMW) is recalling certain 2018 540d, 2018-2020 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 530e, 530e xDrive, X3 sDrive, X3 xDrive, X3 M40i, X3 M, and 2019-2020 X4 xDrive, X4 M40i, X4 M, X7 xDrive, X7 M50i, 740Li, 740Li xDrive, 750Li, 750Li xDrive, 8 Series Convertible and Coupe 840i, 840i xDrive, M850i xDrive, X5 sDrive, X5 xDrive, X5 M50i, X6 xDrive, X6 M50i, 330i, 330i xDrive, M340i, M340i xDrive, Z4 sDrive, Z4 M40i, 740Le xDrive and 745Le xDrive, 2018-2019 640i xDrive Gran Turismo and Rolls-Royce Phantom, 2019 M850i xDrive Gran Coupe and Rolls-Royce Cullinan and 2020 Toyota Supra vehicles. The back-up camera and display settings can be adjusted such that the rear view image is no longer visible and the system will retain that setting the next time the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
- The risk
- The lack of an image in the back-up camera display increases the risk of a crash.
- The fix
- BMW will notify owners, and dealers will update the back-up camera software, free of charge. The recall began November 8, 2019. Owners may contact BMW customer service at 1-800-525-7417 or Rolls-Royce at 1-877-877-3735. Toyota owners may contact Toyota customer service at 1-888-270-9371.
Air bags: knee bolster
NHTSA campaign 19V352000 · reported May 9, 2019 · BMW of North America, LLC · 5,079 vehicles potentially affected
- The problem
- BMW of North America, LLC (BMW) is recalling certain 2019-2020 230i, 230i xDrive, M240i, M240i xDrive, M2 Competition Coupe, 430i, 430i xDrive, 440i, 440i xDrive, M4, and 2019 330i xDrive Sportswagon vehicles. The driver and passenger knee air bag assemblies may have been improperly folded and assembled.
- The risk
- An improperly folded and assembled air bag may not deploy as intended, increasing risk of injury.
- The fix
- BMW will notify owners, and dealers will replace the knee air bag modules, free of charge. The recall began July 8, 2019. Owners may contact BMW customer service at 1-800-525-7417.
What owners report
Recent complaints filed with NHTSA, shortened. These are unverified accounts from owners, not findings.
Aug 26, 2026 · Engine
On … approximately 2:02am my car was seen on fire parked in driveway on […] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Jul 23, 2026 · Electrical system · 110,000 miles · fire reported
The contact owned a 2019 BMW 330I. The contact stated that while the vehicle was parked at the residence in the driveway, there was an abnormal cracking sound coming from outside the residence. The contact checked and became aware that the vehicle was on fire. The vehicle was unoccupied at the time. The contact stated…
Jul 10, 2026 · Forward collision avoidance
KAFAS Mid Camera has software malfunction, internal fault, system does not operate as designed. Takes down all driver assistance features. Module unable to accept new coding/programming. BMW service information - B66 20 19
May 12, 2026 · Engine
Please update recall repair status to repaired for this VIN (dealer repair invoice attached)
Mar 24, 2026 · Electrical system · 81,652 miles
The contact owns a 2019 BMW 330I. The contact received notification of NHTSA Campaign Number: 25V636000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted, but the vehicle had not been diagnosed or repaired. The contact stated that the manufacturer had…
Source: NHTSA recall and complaint data, updated October 27, 2026. Latest complaint received August 26, 2026.