Recalls apply to specific production ranges. To see whether a particular car still has an open recall, enter its VIN at nhtsa.gov/recalls. Repairs for safety recalls are free at authorised dealers.
2001 Buick Regal recalls
Engine and engine cooling: exhaust system, manifold/header/muffler/tail pipe · Engine and engine cooling: engine
NHTSA campaign 15V701000 · reported October 26, 2015 · General Motors LLC · 1,003,556 vehicles potentially affected
- The problem
- General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
- The risk
- Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
- The fix
- The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine and engine cooling
NHTSA campaign 09V116000 · reported April 8, 2009 · GENERAL MOTORS CORP. · 1,497,516 vehicles potentially affected
- The problem
- General motors is recalling 1,497,516 my 1997-2003 buick regal, my 1998-2003 chevrolet lumina, monte carlo and impala, my 1998-1999 oldsmobile intrigue, my 1997-2003 pontiac grand prix vehicles equipped with a 3.8l v6 naturally aspirated engine. Some of these vehicles have a condition in which drops of engine oil may be deposited on the exhaust manifold through hard braking.
- The risk
- If the manifold is hot enough and the oil runs below the heat shield, it may ignite into a small flame and may spread to the plastic spark plug wire channel and beyond increasing the risk of an engine compartment fire.
- The fix
- Dealers will replace the engines front valve cover and front-valve-cover gasket with new parts of an improved design and remove the engines plastic cover and plastic oil-fill-tube extension, free of charge. The recall is expected to begin during may 2016. Owners may contact chevrolet at 1-800-630-2438, oldsmobile at 1-800-630-6537, and pontiac at 1-800-620-7668 or http://www.pontiac.com or http:www.gmownercenter.com.
Engine and engine cooling
NHTSA campaign 08V118000 · reported March 12, 2008 · GENERAL MOTORS CORP. · 207,542 vehicles potentially affected
- The problem
- Gm is recalling 207,542 my 1997-2003 buick regal and pontiac grand prix vehicles equipped with a 3.8l supercharged v-6 engine. These vehicles have higher front rocker cover gasket temperatures, creating the potential for earlier degradation of the front rocker cover gasket and eventual oil seepage.
- The risk
- Certain underhood fires may be caused by drops of engine oil, from seepage or spillage, being deposited on the exhaust manifold through hard braking. If the manifold is hot enough and the oil runs below the heat shield, it may ignite into a small flame and, in some instances, the fire may spread to the plastic spark plug wire channel and beyond.
- The fix
- Dealers will replace the engines front valve cover and front-valve-cover gasket with new parts of an improved design and remove the engines plastic cover and plastic oil-fill-tube extension, along with the 1-3-5 spark plug wire retainers, free of charge. The recall is expected to begin during may 2016. , free of charge. The recall is expected to begin during may 2016. Until the remedy is completed, gm strongly recommends that owners observe the following important precautions (1) that owners do not park their vehicle in a garage, car port, or other structure; (2) if owners notice a burning odor, they should have their dealer inspect the vehicle. The dealer will inspect the vehicle without charge; (3) use premium fuel (91 octane or higher) in the vehicle as recommended in the vehicle's owner manual. Owners may contact buick at 1-866-608-8080 or pontiac at 1-800-620-7668, or through their website at <a href=http://www.gmownercenter.com>http://www.gmownercenter.com</a> .
Seat belts
NHTSA campaign 01V109000 · reported April 6, 2001 · GENERAL MOTORS CORP. · 116,007 vehicles potentially affected
- The problem
- Vehicle description: certain passenger vehicles, equipped with sunvisor located air bag labels, fail to conform to federal motor vehicles safety standard no. 208, "occupant crash protection." these vehicles have a message area less than 30 cm which does not meet the requirements of the standard.
- The risk
- These vehicles do not comply with the standard.
- The fix
- Gm will mail a new bilingual air bag label with installation instructions. However, the customer may bring the label to their dealer for installation free of charge. Owner notification began may 4, 2001. Owners who do not receive the free label and installation instructions within a reasonable time should contact oldsmobile at 1-800-442-6537 or buick at 1-800-521-7300.
Air bags: side/window
NHTSA campaign 00V371000 · reported November 13, 2000 · GENERAL MOTORS CORP. · 12 vehicles potentially affected
- The problem
- Vehicle description: passenger vehicles. Some of these vehicles exhibit a condition in which the driver side impact air bag inflator separates from the air bag module during deployment.
- The risk
- If the inflator separates, the air bag will not deploy properly during a crash and occupant protection would be reduced. If is also possible that a separated inflator could be propelled downward and could result in injury to a rear seat passenger whose foot is positioned approximately under the inflator module.
- The fix
- Dealers will replace the side impact air bag module.
Seat belts
NHTSA campaign 00V228003 · reported August 7, 2000 · GENERAL MOTORS CORP. · 156,305 vehicles potentially affected
- The problem
- Vehicle description: passenger vehicles, light duty trucks, sport utility vehicles, and mini vans equipped with trw seat belt buckle assemblies. The buckle base of these seat belt assemblies were not properly heat treated and therefore do not pass the load bearing requirement of federal motor vehicle safety standard no. 209, "seat belt assemblies."
- The risk
- In the event of a vehicle crash, the occupant may not be properly restrained.
- The fix
- Dealers will inspect the vehicle's safety belt buckle assembly date codes and, if necessary, will replace any safety belt buckle assembly.
What owners report
Recent complaints filed with NHTSA, shortened. These are unverified accounts from owners, not findings.
Feb 1, 2024 · Engine · fire reported
On […], my son drove the car to Wendy’s to get lunch around 12:30 pm. He returned, parked the car in the driveway. My son entered the house and while we were eating lunch the doorbell rang, it was the police informing us that my car was on fire in the driveway. The fire department was called and they eventually…
Apr 19, 2022 · Unknown or other
I have a buick.regal go 3.8 was just notified about recall for under hood fire I have not had this happen yet but I have been a mechanic for.8 years and from what I've seen with my 3.8 and others I have worked on it's not just only the front valve cover and gasket I have noticed that on mine I had oil pooling from…
Apr 19, 2022 · Electrical system
The 2001 buick regal that we have has very inadequate head lights as far as im concerned it is a wiring problem dims are so dim that it's like you have no head lights at all bright are just bright enough to almost see 50 to 100 feet in front of vehicle also this buick is not the only gm vehicle I have experienced this…
Nov 15, 2021 · Structure · fire reported
My car lit on fire under the hood
Sep 18, 2020 · Air bags · 178,000 miles · crash reported
HAD A FRONT TIRE BLOW OUT CAR WENT ACROSS THE ROAD DOWN INTO SMALL DITCH AND STOPPED TO HIT A MAILBOX RESULTING IN THE AIRBAGS DEPLOYING THE PASSENGER SIDE AIRBAG CAME OUT SO HARD THAT IT BROKE THE WINDSHIELD DRIVER SIDE AIRBAG CAME OUT AND RESULTED IN IT BREAKING MY SPINE I'VE HAD TO HAVE ONE SURGERY SINCE THEN AND…
Source: NHTSA recall and complaint data, updated October 27, 2026. Latest complaint received February 1, 2024.