Recalls apply to specific production ranges. To see whether a particular car still has an open recall, enter its VIN at nhtsa.gov/recalls. Repairs for safety recalls are free at authorised dealers.
2003 Chevrolet Avalanche recalls
Seat belts: rear/other
NHTSA campaign 05V163000 · reported April 22, 2005 · GENERAL MOTORS CORP. · 1,359,824 vehicles potentially affected
- The problem
- On certain crew cab pickup trucks and sport utility vehicles, the 2nd row center occupant seat belt routing may make it difficult to position the lap portion of the safety belt low around the hips of occupants, especially smaller occupants, seated in this position. Appropriate use of a child seat or booster seat, as recommended for small children, does improve the fit condition for this user group. In addition to instructions on proper infant and young child restraint (with child seats or boosters), special verbiage for restraining older child is included in the owner's manual. Also, the suggested seat belt fit/routing for adults, irrespective of seating position, is described in the owner's manual text.
- The risk
- A lap portion of the seat belt routing that is not low and snug on the hips can allow the lap belt to ride up on an occupant's abdomen instead of fitting low around their hipbones, and therefore, can expose them to more risk of abdominal and internal organ injury.
- The fix
- Dealers will cut open the guide loop, remove a portion of the loop, and then the remaining two sides should be folded over and secured with a retainer free of charge. The recall began on july 21, 2005. Owners may contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, or hummer at 1-800-732-5493.
Structure: body, tailgate, hinge and attachments
NHTSA campaign 04V129000 · reported March 17, 2004 · GENERAL MOTORS CORP. · 3,662,211 vehicles potentially affected
- The problem
- On certain pickup trucks and sport utility vehicles, the galvanized steel tailgate support cables that retain the tailgate in the full open (horizontal) position may corrode, weaken, and eventually fracture. If both cables fractured, the tailgate would suddenly drop and strike the top surface of the rear bumper.
- The risk
- Anyone sitting or standing on the horizontal surface of the tailgate when both cables fractured could be injured by falling from the tailgate. On vehicles that have had the bumper removed, the tailgate may drop even lower. Additionally, if there is cargo on the tailgate the cargo may fall off if the support cables fracture.
- The fix
- Dealers will replace the cables. Interim owner notification began on april 7, 20004. The recall began on september 24, 2004, when replacement parts were available, and will continue through october 29, 2004. Owners should contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463, or visit www.mygmlink.com, and enter your vehicle identification number.
Service brakes, hydraulic
NHTSA campaign 04V045000 · reported February 4, 2004 · GENERAL MOTORS CORP. · 68,875 vehicles potentially affected
- The problem
- Certain sport utility vehicles, pickup trucks, and passenger vans fail to comply with the requirements of federal motor vehicle safety standard no. 135, ?passenger car brake systems.? Some of these vehicles were produced with an out-of-specification brake hydro-boost housing relief valve bore.
- The risk
- Consequently, the valve o-ring seal may fracture. Steering efforts may be slightly increased while braking or parking. Under certain driving conditions, a fractured seal may require a slight increase in the applied brake pedal effort to achieve the same vehicle deceleration rate as prior to the seat fracture.
- The fix
- Dealers are to replace the hydro-boost relief valve. The recall began on june 18, 2004. Owners should contact cadillac at 1-866-982-2339; chevrolet at 1-800-630-2438; gmc at 1-866-996-9463; or hummer at 1-866-486-6376.
Fuel system, gasoline: storage, tank assembly
NHTSA campaign 03V019000 · reported January 27, 2003 · GENERAL MOTORS CORP. · 5,734 vehicles potentially affected
- The problem
- On certain pickup trucks and sport utility vehicles, vehicles, during a 30 degree left angle frontal impact of sufficient severity, a tear could develop in the mid-frame cross member at its attachment to the left frame rail. If the mid-frame cross member tears during frontal impact and produces a sharp edge, contact of the sharp edge with the fuel tank could result in a puncture of the fuel tank and possible fuel leakage.
- The risk
- Fuel leakage, in the presence of an ignition source, could result in a fire.
- The fix
- Dealers will install a fuel tank shield. Owner notification began february 20, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.
What owners report
Recent complaints filed with NHTSA, shortened. These are unverified accounts from owners, not findings.
Apr 14, 2016 · Service brakes · 170,000 miles
MY 17 YEAR OLD SON WAS ON THE FREEWAY AND THE BRAKE PEDAL TRAVELLED ALL THE WAY TO THE FLOOR WHILE ATTEMPTING TO STOP. THE SERVICE BRAKE SYSTEM LIGHT CAME ON AT THE SAME TIME. STOPPING DISTANCE WAS INCREASED DRAMATICALLY, BY AT LEAST DOUBLE. IF THERE WOULD HAVE BEEN A CURVE OR CAR IN FRONT OF HIM THERE WOULD HAVE BEEN…
Feb 19, 2016 · Electrical system · 70,000 miles
TL* THE CONTACT OWNS A 2003 CHEVROLET AVALANCHE. WHILE DRIVING APPROXIMATELY 65 MPH, THE INSTRUMENT PANEL FAILED. IN ADDITION, THE DRIVER SIDE HEADLIGHT FAILED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE INSTRUMENT PANEL NEEDED TO BE REPLACED…
Aug 7, 2015 · Service brakes · 179,000 miles
BRAKE LINE FAILURE: I HAD A RUPTURED STEEL BREAK LINE FAILURE WHILE APPLYING NORMAL BREAKING PRESSURE ON THE PEDAL. AFTER FURTHER INSPECTION OF BREAK LINES, I FOUND ALL BREAK LINES WERE RUSTED AND IN DANGER OF ALSO RUPTURE.
Jun 17, 2015 · Steering · 181,062 miles
THE OTHER DAY I STARTED NOTICING THAT WHEN I TURN RIGHT (OR LEFT IN REVERSE) AT A LOW RATE OF SPEED THE VEHICLE MAKES A CLUNKING NOISE AND MY STEERING IS AFFECTED. I STARTED LOOKING ONLINE FOR A REMEDY TO THIS PROBLEM AND FOUND THAT SEVERAL PEOPLE HAD THE SAME PROBLEM AND DID NOT KNOW WHERE TO REPORT IT. I DON'T FEEL…
Jun 5, 2015 · Service brakes · 150,000 miles
TL* THE CONTACT OWNS A 2003 CHEVROLET AVALANCHE. WHILE DRIVING AT AN UNKNOWN SPEED, THE BRAKE PEDAL EXTENDED TO THE FLOOR WHEN IT WAS DEPRESSED. THE CONTACT DISCOVERED THAT THE BRAKE LINES NEAR THE DRIVER SIDE DOOR WERE RUSTED AND CORRODED, AND BRAKE FLUID HAD LEAKED FROM THE VEHICLE. THE CONTACT INDICATED THAT THE…
Source: NHTSA recall and complaint data, updated October 27, 2026. Latest complaint received April 14, 2016.