Recalls apply to specific production ranges. To see whether a particular car still has an open recall, enter its VIN at nhtsa.gov/recalls. Repairs for safety recalls are free at authorised dealers.
2004 Chevrolet Impala recalls
Engine and engine cooling: exhaust system, manifold/header/muffler/tail pipe · Engine and engine cooling: engine
NHTSA campaign 15V701000 · reported October 26, 2015 · General Motors LLC · 1,003,556 vehicles potentially affected
- The problem
- General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
- The risk
- Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
- The fix
- The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine and engine cooling: engine
NHTSA campaign 15V201000 · reported April 6, 2015 · General Motors LLC · 330,742 vehicles potentially affected
- The problem
- General Motors LLC (GM) notified the agency on April 2, 2015, that they are is recalling certain model year 2004 Buick Regal vehicles manufactured April 9, 2003, to June 1, 2003, 2004 Chevrolet Impala vehicles manufactured April 8, 2003, to June 23, 2003, and 2004 Chevrolet Monte Carlo vehicles manufactured April 7, 2003, to June 23, 2003. On May 18, 2015, GM expanded the recall to cover an additional 49,751 2004 Pontiac Grand Prix vehicles manufactured January 6, 2003, to June 25, 2004. In the affected vehicles, the valve cover gasket may leak.
- The risk
- The leaking engine oil can drip onto the hot surface of the exhaust manifold, increasing the risk of a fire.
- The fix
- GM will notify owners, and dealers will remove the plastic cover and plastic oil fill tube extension and replace the front valve cover and gasket. These repairs will be done free of charge. The recall began on April 24, 2015. Owners may contact Buick customer service at 1-800-521-7300, Pontiac customer service at 1-800-762-2737 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14574.
Electrical system: ignition
NHTSA campaign 14V400000 · reported July 3, 2014 · General Motors LLC · 5,877,718 vehicles potentially affected
- The problem
- This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
- The risk
- If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
- The fix
- GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Service brakes, hydraulic
NHTSA campaign 04V287000 · reported June 23, 2004 · GENERAL MOTORS CORP. · 47,991 vehicles potentially affected
- The problem
- Certain passenger vehicles were produced with lower than specified torque on both front brake caliper to steering knuckle attachment bolts. With improper torque, the clamp load at the joint may not be adequate to prevent movement between the caliper bracket and knuckle.
- The risk
- Depending on whether one or both bolts backs out or fractures, the result can be locking of the affected wheel during braking and an abrupt steering input in the direction of the locked wheel, reduced braking and noise from the affected wheel, or severing of a brake hose, increased brake pedal travel, and reduced steering control. Reduced braking or steering control could cause a crash.
- The fix
- Dealers are to tighten both bolts to the specified torque. Owner notification began on june 28, 2004. Owners should contact chevrolet 1-800-630-2438 or pontiac 1-800-620-7668.
What owners report
Recent complaints filed with NHTSA, shortened. These are unverified accounts from owners, not findings.
Oct 2, 2026 · Air bags
Car has turned off 3 times while sitting at a light and took hours to turn back on, car shudders when breaking sometimes and abs/traction control/air bag lights will come on, and will shudder and turn off while driving.
Nov 29, 2025 · Electrical system
Cars acceleration causes me to be unable to pick up speed it decelerates up hills small or latg ramps cats constantly fly pass to avoid a multi car pile up it’s very dangerous!
Sep 5, 2025 · Electrical system · 71,000 miles
The contact owns a 2004 Chevrolet Impala. The contact stated that while driving approximately 40 MPH, the vehicle suddenly decelerated to approximately 20 MPH, and the instrument panel went black. The contact stated that the vehicle lost power steering functionality, and then lost motive power and stalled. The contact…
Jul 31, 2024 · Electrical system
The contact owned a 2004 Chevrolet Impala. The contact received notification of NHTSA Campaign Number: 14V400000 (Electrical System) and would like to be removed from the recall distribution list. The local dealer and manufacturer were not contacted.
Jun 21, 2022 · Power train
Wiring harness has got hot and cause a short not getting fuel and more
Source: NHTSA recall and complaint data, updated October 27, 2026. Latest complaint received October 2, 2026.