2003 Chevrolet Suburban recalls and problems

5 recalls and 301 owner complaints on file with NHTSA for the 2003 Chevrolet Suburban.

5
recalls
301
owner complaints
23
complaints mentioning a crash
4
mentioning a fire

Recalls apply to specific production ranges. To see whether a particular car still has an open recall, enter its VIN at nhtsa.gov/recalls. Repairs for safety recalls are free at authorised dealers.

2003 Chevrolet Suburban recalls

Seat belts: rear/other

NHTSA campaign 05V163000 · reported April 22, 2005 · GENERAL MOTORS CORP. · 1,359,824 vehicles potentially affected

The problem
On certain crew cab pickup trucks and sport utility vehicles, the 2nd row center occupant seat belt routing may make it difficult to position the lap portion of the safety belt low around the hips of occupants, especially smaller occupants, seated in this position. Appropriate use of a child seat or booster seat, as recommended for small children, does improve the fit condition for this user group. In addition to instructions on proper infant and young child restraint (with child seats or boosters), special verbiage for restraining older child is included in the owner's manual. Also, the suggested seat belt fit/routing for adults, irrespective of seating position, is described in the owner's manual text.
The risk
A lap portion of the seat belt routing that is not low and snug on the hips can allow the lap belt to ride up on an occupant's abdomen instead of fitting low around their hipbones, and therefore, can expose them to more risk of abdominal and internal organ injury.
The fix
Dealers will cut open the guide loop, remove a portion of the loop, and then the remaining two sides should be folded over and secured with a retainer free of charge. The recall began on july 21, 2005. Owners may contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, or hummer at 1-800-732-5493.

Service brakes, hydraulic

NHTSA campaign 04V045000 · reported February 4, 2004 · GENERAL MOTORS CORP. · 68,875 vehicles potentially affected

The problem
Certain sport utility vehicles, pickup trucks, and passenger vans fail to comply with the requirements of federal motor vehicle safety standard no. 135, ?passenger car brake systems.? Some of these vehicles were produced with an out-of-specification brake hydro-boost housing relief valve bore.
The risk
Consequently, the valve o-ring seal may fracture. Steering efforts may be slightly increased while braking or parking. Under certain driving conditions, a fractured seal may require a slight increase in the applied brake pedal effort to achieve the same vehicle deceleration rate as prior to the seat fracture.
The fix
Dealers are to replace the hydro-boost relief valve. The recall began on june 18, 2004. Owners should contact cadillac at 1-866-982-2339; chevrolet at 1-800-630-2438; gmc at 1-866-996-9463; or hummer at 1-866-486-6376.

Structure

NHTSA campaign 03V094000 · reported March 7, 2003 · SOUTHERN COMFORT CONVERSIONS · 3,674 vehicles potentially affected

The problem
Certain pickup truck, van, and mini van conversions equipped with southern comfort built running boards that contain certain courtesy lights manufactured by american technology components, INC. These units contain a courtesy light or lights that might overheat when the wire harness is exposed to excessive moisture and road salt.
The risk
This overheating condition can cause the running board to melt or cause a fire.
The fix
Dealers will replace the wiring harness on these running boards. Owner notification began march 7, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact southern comfort at 1-800-745-6096.

Structure: body, door, hinge and attachments

NHTSA campaign 03V037000 · reported February 6, 2003 · GENERAL MOTORS CORP. · 107 vehicles potentially affected

The problem
Certain sport utility vehicles fail to comply with requirements of federal motor vehicle safety standard no. 214, "side impact protection." these vehicles are built with four welds on the rear door upper hinge. On some of these vehicles, one or two of the welds may not be to specification.
The risk
As a result, the door strength may be degraded during a side impact vehicle crash.
The fix
Dealers will inspect the welds on the left rear door upper hinge. If a weld is found out-of-specification, a bolt will be installed to secure the hinge. Owner notification began february 17, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact cadillac at 1-800-458-8006, chevrolet at 1-800-222-1020, or gmc at 1-800-462-8782.

Fuel system, gasoline: storage, tank assembly

NHTSA campaign 03V019000 · reported January 27, 2003 · GENERAL MOTORS CORP. · 5,734 vehicles potentially affected

The problem
On certain pickup trucks and sport utility vehicles, vehicles, during a 30 degree left angle frontal impact of sufficient severity, a tear could develop in the mid-frame cross member at its attachment to the left frame rail. If the mid-frame cross member tears during frontal impact and produces a sharp edge, contact of the sharp edge with the fuel tank could result in a puncture of the fuel tank and possible fuel leakage.
The risk
Fuel leakage, in the presence of an ignition source, could result in a fire.
The fix
Dealers will install a fuel tank shield. Owner notification began february 20, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.

Most reported problems

Areas named in owner complaints to NHTSA. One complaint can name several areas.

What owners report

Recent complaints filed with NHTSA, shortened. These are unverified accounts from owners, not findings.

May 21, 2026 · Electrical system · 291,000 miles

Odometer Fraud. The contact purchased a 2003 Chevrolet Suburban. It was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 291,000 and at the time of inspection, it was discovered that the odometer was tampered with, and without disclosure…

Sep 17, 2025 · Trailer hitches · 150,000 miles · crash reported

The contact owns a 2003 Chevrolet Suburban. The contact stated that while driving at 40 MPH, the contact noticed the trailer attached was moving from left to right independently, and the trailer detached from his vehicle. The contact mentioned that he lost control of the vehicle into a parallel position when another…

Jul 19, 2024 · Electrical system

The cluster of the speedometer

Jan 29, 2021 · Service brakes · 199,000 miles

I WAS DRIVING ON THE FREEWAY AND ALL OF A SUDDEN I HAD 0% OF MY BRAKES AND ALL THE BRAKE FLUID WAS GONE MY EMERGENCY BRAKE ALSO FAILED PRIOR TO THIS I PUT IN BRAKE FLUID AND IT ALL LEAKED OUT WITHIN A MATTER OF MOMENTS

Sep 23, 2020 · Air bags · 173,000 miles · crash reported

TL* THE CONTACT OWNED A 2003 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE TOWING HIS DAUGHTER'S VEHICLE AT ABOUT 60 MPH, ANOTHER VEHICLE CRASHED INTO THE VEHICLE BEING TOWED. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED A HEAD AND LOWER BACK INJURY. THE FRONT PASSENGER (HIS DAUGHTER) SUSTAINED A BACK…

Suburban model years compared

YearRecallsComplaintsCrashesFires
2000 8281137
2001 6440355
2002 2286245
2003 5301234
2004 4204126
2005 612941
2006 12301

Across all years, the 2001 Suburban has the most complaints (440). All Chevrolet Suburban years →

Questions

Does the 2003 Chevrolet Suburban have any recalls?
Yes. NHTSA lists 5 recalls for the 2003 Chevrolet Suburban, the most recent reported on April 22, 2005 (Seat belts: rear/other). Check a specific car by its VIN at nhtsa.gov/recalls.
What are the most common problems with the 2003 Chevrolet Suburban?
Owners have filed 301 complaints with NHTSA. The most frequently reported area is electrical system (81 complaints), followed by service brakes (63).
How many 2003 Chevrolet Suburban complaints mention a crash or fire?
23 of 301 complaints report a crash and 4 a fire; 30 injuries were reported in total. Complaints are unverified reports from owners.

Source: NHTSA recall and complaint data, updated October 27, 2026. Latest complaint received May 21, 2026.