Recalls apply to specific production ranges. To see whether a particular car still has an open recall, enter its VIN at nhtsa.gov/recalls. Repairs for safety recalls are free at authorised dealers.
2000 GMC Sierra recalls
Structure: body, tailgate, hinge and attachments
NHTSA campaign 06V066000 · reported March 8, 2006 · GENERAL MOTORS CORP. · 805,368 vehicles potentially affected
- The problem
- Certain pickup trucks have galvanized-braided-steel tailgate support cables used to support the tailgate in the full open (horizontal) position. Over time these cables can corrode and fracture when loads are applied to them.
- The risk
- If one cable fractures, the remaining cable may retain the tailgate in a horizontal position. If both cables fracture, the tailgate would drop and strike the top surface of the rear bumper. If anyone is sitting or standing on the horizontal surface of the tailgate when both cables fractured, they could fall and be injured. On vehicles without a bumper, the tailgate may drop to a lower position.
- The fix
- Dealers will replace the galvanized support cables with stainless steel support cables. In addition, dealers are to inspect the tailgate hinge and replace it, if necessary. The recall is expected to begin during april 2006. Owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.
Service brakes, hydraulic: antilock/traction control/electronic limited slip
NHTSA campaign 05V379000 · reported August 29, 2005 · GENERAL MOTORS CORP. · 1,353,718 vehicles potentially affected
- The problem
- Certain pickup trucks and sport utility vehicles may experience unwanted antilock brake system (ABS) activation. This condition is more likely to occur in environmentally corrosive areas. This recall will be launched in the "salt belt" states of connecticut, delaware, illinois, indiana, iowa, maryland, massachusetts, maine, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin and the district of columbia only.
- The risk
- This can cause increased stopping distances during low-speed brake applications, which could result in a crash.
- The fix
- Dealers are to remove the wheel speed sensor and thoroughly clean the wheel speed sensor mounting surface on the bearing, apply rust inhibitor to the cleaned surface, grease the mounting surface, reinstall the wheel speed sensor, and check the peak-to-peak output voltage to ensure the wheel speed signal is within specifications. The recall began september 22, 2005. Owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.
Parking brake
NHTSA campaign 05V161000 · reported April 22, 2005 · GENERAL MOTORS CORP. · 90,242 vehicles potentially affected
- The problem
- On certain pickup trucks equipped with manual transmissions and built with either pbr parking brake systems or trw parking brake systems, the parking brake friction linings may wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.
- The risk
- If the parking brake does not hold, unintended vehicle movement could occur, which could result in a crash.
- The fix
- Dealers will install a low-force spring clip retainer for vehicles equipped with a pbr parking brake system. On vehicles equipped with the trw parking brake system, dealers will install a redesigned parking brake cable assembly. The recall began on july 29, 2005. Owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.
Power train: driveline, driveshaft
NHTSA campaign 05V005000 · reported January 7, 2005 · GENERAL MOTORS CORP. · 98,221 vehicles potentially affected
- The problem
- Some pickup trucks, vans, and sport utility vehicles equipped with a hydraulic pump driveshaft that can fracture, resulting in immediate loss of hydraulic power steering assist. On certain vehicles equipped with hydro-boost power brakes, the same condition can result in loss of power assist for braking after the reserve pressure is depleted.
- The risk
- An inoperative pump can cause increased steering effort, and in hydro-boost equipped vehicles also increased braking effort, but does not completely eliminate the ability to steer or slow the vehicle.
- The fix
- Dealers will replace the hydraulic pump. The campaign began on february 14, 2005. Owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.
Structure: body, tailgate, hinge and attachments
NHTSA campaign 04V129000 · reported March 17, 2004 · GENERAL MOTORS CORP. · 3,662,211 vehicles potentially affected
- The problem
- On certain pickup trucks and sport utility vehicles, the galvanized steel tailgate support cables that retain the tailgate in the full open (horizontal) position may corrode, weaken, and eventually fracture. If both cables fractured, the tailgate would suddenly drop and strike the top surface of the rear bumper.
- The risk
- Anyone sitting or standing on the horizontal surface of the tailgate when both cables fractured could be injured by falling from the tailgate. On vehicles that have had the bumper removed, the tailgate may drop even lower. Additionally, if there is cargo on the tailgate the cargo may fall off if the support cables fracture.
- The fix
- Dealers will replace the cables. Interim owner notification began on april 7, 20004. The recall began on september 24, 2004, when replacement parts were available, and will continue through october 29, 2004. Owners should contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463, or visit www.mygmlink.com, and enter your vehicle identification number.
Air bags: frontal, sensor/control module-inactive
NHTSA campaign 02V178000 · reported July 1, 2002 · GENERAL MOTORS CORP. · 525,254 vehicles potentially affected
- The problem
- On certain pickup and utility trucks, some of these vehicles have an air bag sensing diagnostic module (sdm) which contains an anomaly that could result in the driver and passenger's air bag failing to deploy during certain frontal crashes.
- The risk
- In a vehicle crash, front seat occupants may receive more severe injuries.
- The fix
- Dealers will recalibrate the sdm on the affected vehicles. Owner notification began august 28, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.
Service brakes, hydraulic: foundation components, hoses, lines/piping, and fittings
NHTSA campaign 00V345000 · reported October 30, 2000 · GENERAL MOTORS CORP. · 1,383,922 vehicles potentially affected
- The problem
- Vehicle description: light duty pickup trucks and sport utility vehicles. Some of these vehicles have a clearance condition between the front right-hand brake pipe and the body cross sill that could decrease to the point of allowing contact during the life of the vehicle. If contact occurs and the brake pipe becomes damaged, in half of the brake system there can be a loss of brake fluid and pressure. The brake warning lamp will be activated when the brake fluid level reaches the indicator limit.
- The risk
- During braking, the pedal will be lower than normal and stopping distances will be longer. If this occurs when stopping distance is limited, a crash could occur.
- The fix
- Dealers will inspect the front right-hand brake pipe for wear. If there are signs of wear, this section of the brake pipe will be replaced with a new designed brake pipe section. If there are not signs of wear on the brake pipe, the dealer will install a spacer clip to ensure sufficient clearance between the brake pipe and the body cross sill.
Service brakes, hydraulic: antilock/traction control/electronic limited slip
NHTSA campaign 00V055000 · reported February 28, 2000 · GENERAL MOTORS CORP. · 10,674 vehicles potentially affected
- The problem
- Vehicle description: light duty pickup trucks equipped with 4-wheel disc brakes. Some of these vehicles have an antilock brake system (ABS) motor containing an out-of-specification spring clip. This clip could allow the motor bearing to become misaligned. If misalignment occurs, eventually the ABS would be non-functional.
- The risk
- The base brakes would remain fully functional, but the dynamic rear proportioning (drp) system, which optimizes front to rear brake balance, would become inoperative.
- The fix
- Dealers will replace the brake pressure module valve assembly.
What owners report
Recent complaints filed with NHTSA, shortened. These are unverified accounts from owners, not findings.
Mar 20, 2025 · Air bags · 220,000 miles · crash reported
The contact owned a 2000 GMC Sierra. The contact stated while driving at approximately 70 MPH the driver's side front wheel control arm had fractured and the vehicle went out of control. The contact stated that the vehicle rolled over three times. The contact stated that the vehicle rolled off of the road and stopped…
Nov 2, 2015 · Service brakes · 147,000 miles
MY PICKUP TRUCK WAS IN MOTION WHEN DRIVING ON A CITY STREET I HAD TO SLOW DOWN. THE BRAKE-PETAL WENT ALMOST COMPLETELY TO THE FLOOR. I ALMOST HIT THE VEHICLE IN FRONT OF ME WHILE TRYING TO STOP. AFTER PULLING TO THE SIDE OF STREET I CHECKED UNDER THE TRUCK AND DISCOVERED THAT THE REAR METAL BRAKE LINE ADJACENT TO THE…
Jun 24, 2015 · Service brakes · 135,000 miles
WHILE TOWING MY BOAT I EXPERIENCED BRAKE FAILURE. THE PEDAL WENT TO THE FLOOR WITH NO PRESSURE. BRAKE WARNING LIGHT DID NOT COME ON. WE WERE ON A DIRT ROAD WITH NO TRAFFIC AND WERE ABLE TO STOP WITHOUT INCIDENT. AFTER INSPECTING THE BRAKE LINES A LEAK WAS FOUND IN ONE OF THE LINES UNDER THE DRIVERS SIDE DOOR BEFORE…
May 3, 2015 · Service brakes · 56,000 miles
THE BRAKE LINES HAVE ROTTED OUT AND FAILED IN TRAFFIC MULTIPLE TIMES WITHOUT NOTICE. ALSO THE LEAF SPRING HANGERS ROTTED AND BROKE. THE REAR BUMPER IS A RUSTED MESS. THE UNDERCARRIAGE OF THE TRUCK LOOKS LIKE SOMETHING THAT WAS WASHED ASHORE. HEAVY DUTY ROT. THE BODY AND CAB INSIDE STILL LOOK NEW. SOMETHING WRONG WITH…
Jan 31, 2015 · Service brakes · 152,630 miles
BRAKES FAILED UNEXPECTEDLY. THE PEDAL WENT ALL THE WAY TO THE FLOOR AND BARELY SLOWED DOWN THE TRUCK AT ALL. THIS WAS DUE TO A BRAKE LINE THAT RUSTED THROUGH. THE REPAIR WAS $765. HAD I BEEN IN AN AREA WITH HIGHER TRAFFIC THERE WOULD HAVE BEEN AN ACCIDENT.
Source: NHTSA recall and complaint data, updated October 27, 2026. Latest complaint received March 20, 2025.