Recalls apply to specific production ranges. To see whether a particular car still has an open recall, enter its VIN at nhtsa.gov/recalls. Repairs for safety recalls are free at authorised dealers.
2003 GMC Yukon recalls
Seat belts: rear/other
NHTSA campaign 05V163000 · reported April 22, 2005 · GENERAL MOTORS CORP. · 1,359,824 vehicles potentially affected
- The problem
- On certain crew cab pickup trucks and sport utility vehicles, the 2nd row center occupant seat belt routing may make it difficult to position the lap portion of the safety belt low around the hips of occupants, especially smaller occupants, seated in this position. Appropriate use of a child seat or booster seat, as recommended for small children, does improve the fit condition for this user group. In addition to instructions on proper infant and young child restraint (with child seats or boosters), special verbiage for restraining older child is included in the owner's manual. Also, the suggested seat belt fit/routing for adults, irrespective of seating position, is described in the owner's manual text.
- The risk
- A lap portion of the seat belt routing that is not low and snug on the hips can allow the lap belt to ride up on an occupant's abdomen instead of fitting low around their hipbones, and therefore, can expose them to more risk of abdominal and internal organ injury.
- The fix
- Dealers will cut open the guide loop, remove a portion of the loop, and then the remaining two sides should be folded over and secured with a retainer free of charge. The recall began on july 21, 2005. Owners may contact cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, gmc at 1-866-996-9463, or hummer at 1-800-732-5493.
Service brakes, hydraulic
NHTSA campaign 04V045000 · reported February 4, 2004 · GENERAL MOTORS CORP. · 68,875 vehicles potentially affected
- The problem
- Certain sport utility vehicles, pickup trucks, and passenger vans fail to comply with the requirements of federal motor vehicle safety standard no. 135, ?passenger car brake systems.? Some of these vehicles were produced with an out-of-specification brake hydro-boost housing relief valve bore.
- The risk
- Consequently, the valve o-ring seal may fracture. Steering efforts may be slightly increased while braking or parking. Under certain driving conditions, a fractured seal may require a slight increase in the applied brake pedal effort to achieve the same vehicle deceleration rate as prior to the seat fracture.
- The fix
- Dealers are to replace the hydro-boost relief valve. The recall began on june 18, 2004. Owners should contact cadillac at 1-866-982-2339; chevrolet at 1-800-630-2438; gmc at 1-866-996-9463; or hummer at 1-866-486-6376.
Structure
NHTSA campaign 03V094000 · reported March 7, 2003 · SOUTHERN COMFORT CONVERSIONS · 3,674 vehicles potentially affected
- The problem
- Certain pickup truck, van, and mini van conversions equipped with southern comfort built running boards that contain certain courtesy lights manufactured by american technology components, INC. These units contain a courtesy light or lights that might overheat when the wire harness is exposed to excessive moisture and road salt.
- The risk
- This overheating condition can cause the running board to melt or cause a fire.
- The fix
- Dealers will replace the wiring harness on these running boards. Owner notification began march 7, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact southern comfort at 1-800-745-6096.
Structure: body, door, hinge and attachments
NHTSA campaign 03V037000 · reported February 6, 2003 · GENERAL MOTORS CORP. · 107 vehicles potentially affected
- The problem
- Certain sport utility vehicles fail to comply with requirements of federal motor vehicle safety standard no. 214, "side impact protection." these vehicles are built with four welds on the rear door upper hinge. On some of these vehicles, one or two of the welds may not be to specification.
- The risk
- As a result, the door strength may be degraded during a side impact vehicle crash.
- The fix
- Dealers will inspect the welds on the left rear door upper hinge. If a weld is found out-of-specification, a bolt will be installed to secure the hinge. Owner notification began february 17, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact cadillac at 1-800-458-8006, chevrolet at 1-800-222-1020, or gmc at 1-800-462-8782.
What owners report
Recent complaints filed with NHTSA, shortened. These are unverified accounts from owners, not findings.
May 2, 2025 · Engine
My 03 Yukon Denali is experiencing all of the same things that the recall on the 2021 Yukon is experiencing. What do I do? The recall notice I am referring to is N252494000
Oct 6, 2022 · Power train · 200,000 miles
The contact owns a 2003 GMC Yukon. The contact stated that while driving at various speed, the vehicle would stall as the battery warning light appeared on the instrument panel. The contact also stated that the vehicle would shake upon depression of the brake pedal without warning. The vehicle was taken to the…
Apr 18, 2022 · Engine · 150,000 miles
The contact owns a 2003 GMC Yukon. The contact stated that upon purchasing the vehicle from a towing company, the vehicle would not start. The battery was instantly replaced. The contact stated that the vehicle would wobble and shut off inadvertently while driving. The vehicle was taken to an independent mechanic…
Jul 11, 2021 · Suspension
When I turn out of a parking spot it clicks and pops replaced ball joints shocks tie rods everything it won't go away and it does it when I pull into a parking spot
Dec 13, 2020 · Engine · 175,000 miles
FOR THE PAST FEW MONTHS MY CAR STALLS WHILE DRIVING I'VE REPLACED FUEL PUMP. KNOCK SENSORS COILS AND PLUGS AND IT STILL DOES IT AND DOES NOT THROW A TROUBLE CODE.
Source: NHTSA recall and complaint data, updated October 27, 2026. Latest complaint received May 2, 2025.