Recalls apply to specific production ranges. To see whether a particular car still has an open recall, enter its VIN at nhtsa.gov/recalls. Repairs for safety recalls are free at authorised dealers.
2019 Mercedes-Benz Sprinter (vs30) recalls
Electrical system: wiring, fuses and circuit breakers · Visibility: defroster/defogger/hvac system, fan/motor
NHTSA campaign 23V100000 · reported February 17, 2023 · Daimler Vans USA, LLC · 52,993 vehicles potentially affected
- The problem
- Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes-Benz Sprinter VS30 and Freightliner Sprinter VS30 vehicles. The heating, ventilation, and air conditioning (HVAC) blower motor circuit may be inadequate, which can allow the wiring harness to overheat.
- The risk
- A wiring harness that overheats increases the risk of a fire.
- The fix
- Owners are advised to only operate the HVAC front blower in manual (not automatic) mode whenever the engine is on. Do not use the maximum blower or lowest/highest temperature settings until the remedy is performed. Dealers will relocate and replace the fuse and wiring harness, free of charge. Owner notification letters were mailed June 26, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is 8297010.
Electronic stability control (ESC): control module, software
NHTSA campaign 21V360000 · reported May 17, 2021 · Daimler Vans USA, LLC · 168 vehicles potentially affected
- The problem
- Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter vehicles equipped with the camper upfit option. The Electronic Stability Control (ESP) software was not updated for vehicles with a higher center of gravity.
- The risk
- The ESP may not respond as intended during certain driving scenarios, increasing the risk of a crash.
- The fix
- Dealers will update the software, free of charge. Owner notification letters were mailed on July 2, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3HOLAPLI.
Steering: hydraulic power assist, hose, piping, and connections
NHTSA campaign 21V241000 · reported April 6, 2021 · Daimler Vans USA, LLC · 4,444 vehicles potentially affected
- The problem
- Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The hydraulic power steering return line hoses may detach and cause hydraulic fluid to leak.
- The risk
- A hydraulic fluid leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
- The fix
- DVUSA will notify owners, and dealers will install a screw-type clamp, free of charge. Owner notification letters were mailed on May 28, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is NV3LETULPX.
Equipment: other, labels
NHTSA campaign 21V237000 · reported April 5, 2021 · Daimler Vans USA, LLC · 1 vehicles potentially affected
- The problem
- Daimler Vans USA, LLC (DVUSA) is recalling one 2019 Mercedes Benz Sprinter vehicle. The VIN number listed on the vehicle's dash board, certification label, and body-in-white do not match. As such, this vehicle fails to comply with the requirements of 49 CFR Part 567, "Certification."
- The risk
- The consumer may not receive information about open safety-recall campaigns, increasing the risk of injury, a crash, or fire.
- The fix
- DVUSA will notify the owner, and a dealer will replace the VIN listed on the vehicle's dash board and certification label, free of charge. The recall began May 11, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3VINCHA.
Equipment: other, owners/service/other manual
NHTSA campaign 20V756000 · reported December 8, 2020 · Daimler Vans USA, LLC · 9 vehicles potentially affected
- The problem
- Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter vehicles. These vehicles may have been delivered with a version of the printed and digital operator's manual that may be inaccurate and/or incomplete.
- The risk
- If the operator relies on the provided owner's manual, the information about vehicle functions and other safety relevant information may be inaccurate and/or incomplete, which could lead to improper operation of the vehicle and potentially increase the risk of a crash or injury.
- The fix
- DVUSA will notify owners, and dealers will replace the printed version of the operator's manual with the latest version and update the software of the digital version, free of charge. DVUSA distributed owners an interim notification on January 22, 2021. The recall began March 17, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3PRIDIBA.
Fuel system, gasoline: delivery, fuel pump
NHTSA campaign 20V453000 · reported August 4, 2020 · Daimler Vans USA, LLC · 46 vehicles potentially affected
- The problem
- Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The affected Sprinter vehicles from platform 907 (VS30) might have an open port on the fuel delivery module (fuel pump).
- The risk
- An open port on the fuel pump module may result in fuel leaking onto the roadway, increasing the risk of a crash.
- The fix
- DVUSA will notify owners, and dealers will check for the additional nozzle on the fuel pump and install a closure onto the nozzle as needed, free of charge. The recall began September 18, 2020. Owners may contact DVUSA customer service at 1-800-367-6372. MBUSA's number for this recall is VS3KRASTUF.
Suspension: rear, springs, leaf spring assembly, leaf
NHTSA campaign 20V426000 · reported July 27, 2020 · Daimler Vans USA, LLC · 26 vehicles potentially affected
- The problem
- Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The incorrect leaf spring shims may have been installed between the rear axle and the leaf springs possibly affecting the vehicle's handling. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
- The risk
- The incorrect leaf spring shims may negatively affect vehicle handling, increasing the risk of a crash.
- The fix
- DVUSA will notify owners, and dealers will replace the leaf spring shims on both sides, renew the spring brackets, check the rubber buffers for wear, renewing them if necessary, and adjust the headlamps, free of charge. The manufacturer has not yet provided a schedule for recall notification. DVUSA issued owners an interim notification on September 18, 2020. The recall began October 1, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3LEFSPRI.
Suspension: rear · Suspension: front, stabilizer bar
NHTSA campaign 20V427000 · reported July 27, 2020 · Daimler Vans USA, LLC · 4 vehicles potentially affected
- The problem
- Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter vehicles. The chassis may be missing the additional stabilization required for its cargo capacity. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
- The risk
- If the vehicle is operated without the additional stabilization, vehicle handling could be affected, increasing the risk of a crash.
- The fix
- DVUSA will notify owners, and dealers will upgrade the chassis by replacing the stabilizer bar on the front axle and replacing shock absorbers and installing a stabilizer bar on the rear axle, free of charge. DVUSA issued owners an interim notification on September 18, 2020. The recall began October 1, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3FAHRBA.
Seats · Air bags: side/window · Electrical system: wiring
NHTSA campaign 20V322000 · reported June 3, 2020 · Daimler Vans USA, LLC · 11,013 vehicles potentially affected
- The problem
- Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz and Freightliner Spinter vans (platform 970 (VS30)), equipped with swivel seats. The wiring harnesses for the front seats may have been routed incorrectly and could become jammed and damaged in the swivel seat frames.
- The risk
- If the wiring harness is damaged, the side air bag within the seat may deploy inadvertently or not deploy as designed in the event of a crash, increasing the risk of injury to vehicle occupants.
- The fix
- DVUSA will notify owners, and an authorized Mercedes-Benz or Freightliner Sprinter dealer will inspect the wire harness routing for both front seats and will repair the wiring and add clips or cable ties as needed, free of charge. The recall began August 24, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DREHSIK.
Equipment: other, owners/service/other manual
NHTSA campaign 20V180000 · reported March 26, 2020 · Daimler Vans USA, LLC · 52,127 vehicles potentially affected
- The problem
- Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Freightliner Sprinter and Mercedes-Benz Sprinter vehicles. The Operator's Manual may not contain the correct information about how the automatic parking function ("Auto-P") operates.
- The risk
- If the driver relies on the Auto-P function as described in the Operator's Manual, vehicle rollaway or movement may occur, increasing the risk of a crash.
- The fix
- DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will provide the correct description of the Auto-P function for the Operator's Manual, free of charge. The recall began May 18, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BAUTOP.
Structure: frame and members, underbody shields · Service brakes, air: supply, hoses, lines/piping, and fittings
NHTSA campaign 20V181000 · reported March 25, 2020 · Daimler Vans USA, LLC · 48,791 vehicles potentially affected
- The problem
- Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Freightliner Sprinter and Mercedes-Benz Sprinter vehicles. The rear part of the fender liner on the front axle may contact and chafe the brake hose, possibly resulting in a loss of brake fluid.
- The risk
- Loss of brake fluid can extend the distance needed to stop the vehicle, increasing the risk of a crash.
- The fix
- DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will inspect and replace the brake hoses, as necessary. Additionally, the fender liners will be modified. All services will be performed free of charge. The recall began May 8, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BRADVER.
Equipment
NHTSA campaign 19V908000 · reported December 19, 2019 · Daimler Vans USA, LLC · 183 vehicles potentially affected
- The problem
- Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The lashing rails on the side walls may not have been properly installed, possibly resulting in the lashing rails detaching.
- The risk
- If the lashing rails disconnect, the cargo could become unsecured, increasing the risk of a crash.
- The fix
- DVUSA will notify owners, and dealers will correctly affix the lashing rails to the side walls, free of charge. DVUSA issued owners an interim notification on February 7, 2020. The recall began April 15, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3ZUSCHI.
Exterior lighting: fog lights
NHTSA campaign 19V121000 · reported February 22, 2019 · Daimler Vans USA, LLC · 1,197 vehicles potentially affected
- The problem
- Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter VS30 vehicles equipped with LED rear fog lights. The lights may not illuminate, despite the rear fog light switch being turned on.
- The risk
- The lack of functioning rear fog lamps prevents the enhanced visibility of the vehicle to other drivers on the road, increasing the risk of crash.
- The fix
- DVUSA will notify owners, and dealers will update the software settings of the control unit body controller, free of charge. The recall began April 18, 2019. Owners may contact DVUSA customer service at 1-877-762-8267.
Steering: gear box, shaft sector
NHTSA campaign 19V070000 · reported January 31, 2019 · Daimler Vans USA, LLC · 4,358 vehicles potentially affected
- The problem
- Daimler Vans USA, LLC (Daimler Vans) is recalling certain 2019 Mercedes-Benz Sprinter VS30 vehicles. The steering shaft that connects to the steering gear may disconnect without warning.
- The risk
- The steering shaft disconnecting from the steering gear can cause a sudden loss of steering control, increasing risk of a crash.
- The fix
- Daimler Vans will notify owners, advising them to stop driving the vehicle immediately. Dealers will inspect the bolts connecting the steering shaft to the steering gear, fully tightening and/or adjusting them, as necessary, free of charge. The recall began February 15, 2019. Owners may contact Daimler Van's customer service at 1-800-367-6372. Daimler Van's number for this recall is 2019010006.
What owners report
Recent complaints filed with NHTSA, shortened. These are unverified accounts from owners, not findings.
Dec 23, 2023 · Service brakes · fire reported
At approximately 104 miles into a recent trip in our RV, while traveling at highway speed under cruise control, we noticed a strange odor. Almost at the same moment we immediately lost engine and braking power. The check engine light came on. We then noticed smoke coming from the engine compartment and noxious fumes…
Apr 27, 2022 · Electrical system · 15,000 miles
The contact owns a 2019 Mercedes-Benz Sprinter 3500. The contact stated that while seated in the swivel chair inside the vehicle, she turned the swivel chair around to watch the television and several unknown warning lights started flashing on and off and the vehicle would not start. The contact stated that an…
Dec 17, 2021 · Trailer hitches · 15,000 miles
The contact owns a 2020 Tiffin Wayfarer Motorhome built on a 2019 Mercedes-Benz Sprinter 3500/4500 chassis. The contact stated that while driving approximately 55-65 MPH, the water tank fell onto the exhaust system. The contact received notification of NHTSA campaign numbers: 21V610000 (Trailer Hitches) and 21V753000…
Mar 25, 2021 · Power train · 21,130 miles · crash reported
ACCIDENT ON 10/15/2020, UNOCCUPIED VEHICLE ROLLED FROM A PARKED POSITION DOWN A HILL AND STRUCK A HOUSE. THE VEHICLE IS DESIGNED TO HAVE THE TRANSMISSION AUTOMATICALLY SHIFT TO PARK WHEN THE DRIVER'S DOOR IS OPEN, AND THIS SYSTEM WAS FUNCTIONAL AT THE TIME OF THE INCIDENT. DISENGAGEMENT OF THE PARKING PAWL WAS THE…
Source: NHTSA recall and complaint data, updated October 27, 2026. Latest complaint received December 23, 2023.