Recalls apply to specific production ranges. To see whether a particular car still has an open recall, enter its VIN at nhtsa.gov/recalls. Repairs for safety recalls are free at authorised dealers.
2002 Nissan Frontier recalls
Steering: column
NHTSA campaign 10V554000 · reported November 11, 2010 · NISSAN NORTH AMERICA, INC. · 500,552 vehicles potentially affected
- The problem
- Nissan is recalling certain model year 2002-2004 frontier vehicles manufactured from july 9, 2001 through october 20, 2004, and model year 2002-2004, xterra vehicles manufactured from july 9, 2001, through january 6, 2005. Over time corrosion may form in the lower steering column joint and limit movement of the joint. The limited movement of this joint may create excessive load on the lower steering column shaft. If the vehicle continues to be driven in this condition, it may lead to cracking of the shaft during low speed maneuvers that require large steering inputs.
- The risk
- The shaft may break which could result in loss of steering control during these low speed maneuvers increasing the risk of a crash.
- The fix
- The steering column shaft and joint will be replaced with a shaft of a different design. This service will be performed free of charge. The recall began on december 13, 2010. Owners may contact nissan at 1-800-647-7261.
Fuel system, gasoline: delivery, fuel pump
NHTSA campaign 04V230000 · reported May 24, 2004 · NISSAN NORTH AMERICA, INC. · 586,196 vehicles potentially affected
- The problem
- On certain pickup trucks equipped with six cylinder engines and sport utility vehicles equipped with four or six cylinder engines, the fuel pump terminal on the fuel-sending unit can develop a crack in the plastic molding. This can cause the terminal strip to corrode under some environmental conditions.
- The risk
- If corrosion occurs, the terminal strip could eventually break causing the fuel pump to stop operation. This will result in not being able to start the engine or cause the engine to stop running without warning, which can result in a crash.
- The fix
- In the following states, dealers will replace the fuel-sending unit. These states are connecticut, delaware, illinois, indiana, iowa, kentucky, maine, maryland, massachusetts, michigan, minnesota, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, tennessee, vermont, virginia, west virginia, wisconsin, and the district of columbia. In the other states, the dealer will inspect the fuel pump terminal on the sending unit for corrosion. If corrosion is present, the dealer will replace the unit. If there is not corrosion, the dealer will apply sealant to the terminal housing to help prevent corrosion in the future. Owner notification began on june 28, 2004. Owners should contact nissan at 1-800-647-7261.
Vehicle speed control
NHTSA campaign 02V298000 · reported November 12, 2002 · NISSAN NORTH AMERICA, INC. · 5,000 vehicles potentially affected
- The problem
- On certain pickup trucks and sport utility vehicles equipped with a supercharger, under certain conditions, such as full throttle in low gear when the engine is not fully warmed up and at cold ambient temperature, the amount of intake air flow through the air flow meter may exceed the maximum preset diagnosis limit value.
- The risk
- This will cause the engine control system to go into the failsafe mode. Under this condition, the malfunction indicator lamp will illuminate and engine speed will not exceed 2400 rpm regardless of the throttle position, increasing the risk of a crash.
- The fix
- Dealers will reprogram the electronic control module. Owner notification began january 15, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact nissan at 1-800-647-7261.
Suspension: rear
NHTSA campaign 02V299000 · reported November 12, 2002 · NISSAN NORTH AMERICA, INC. · 143,000 vehicles potentially affected
- The problem
- On certain pickup trucks and sport utility vehicles, water may enter the rear axle housing due to inadequate sealing of the anti-lock braking system (ABS) sensor.
- The risk
- This can result in corrosion and eventual failure of the wheel bearing. If this occurs, the wheel assembly could separate from the vehicle increasing the risk of a crash.
- The fix
- Dealers will inspect the rear axle for water intrusion and any affected components will be replaced. The ABS sensor will be resealed to prevent water intrusion. Owner notification began december 10, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact nissan at 1-800-647-7261.
What owners report
Recent complaints filed with NHTSA, shortened. These are unverified accounts from owners, not findings.
Dec 18, 2024 · Engine
The main issue on the Nissan Frontier that I just bought a few months ago that I need to report that I think should be recalled item is the passenger side exhaust manifold is cracked and it makes ticking noises the exhaust is loud and I am definitely getting exhaust fumes drawn into the cab especially when I turn the…
May 26, 2022 · Fuel system, gasoline · 200,000 miles
The contact owns a 2002 Nissan Frontier. The contact stated while driving approximately 65 MPH, the vehicle lost motive power and stalled. There were no warning lights illuminated. The contact was able to restart the vehicle and drove home safely. The contact performed an inspection and noticed that the fuel pump was…
Jan 10, 2022 · Steering
The contact owns a 2002 Nissan Frontier. The contact stated while driving at various speeds, the steering wheel became difficult to turn. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 10V554000 (Steering). The vehicle was repaired however, the failure persisted. The vehicle was…
Mar 1, 2021 · Air bags · 142,000 miles
SEAT BELT LIGHT ON THE DASH TURNED ON AND CONTINUED FLASHING. THE DIAGNOSIS READ ON IT WAS TENSIONER ON SYSTEM RESTRAINT. SENSOR WAS REPLACED BUT THE SRS LIGHT CONTINUED TO FLASH AND NOW HAS LOCKED MY SEAT BELTS. DRIVER'S SEAT BELT WILL NOT RELEASE SO I HAVE BEEN HAVING TO DRIVE WITHOUT A SEAT BELT. ALL WIRING ON…
Mar 10, 2020 · Fuel/propulsion system · 125,000 miles
NHTSA CAMPAIGN #04V230000 APPLIES TO MY 2002 FRONTIER BUT IT IS NOT COVERED BECAUSE ITS VIN IS A SC(SUPERCHARGED) MODEL IT HAS THE SAME GASTANK,SENDING UNIT, ORINGS AS TRUCKS IN THE RECALL BUT MY MODEL IS NOT INCLUDED IN RECALL
Source: NHTSA recall and complaint data, updated October 27, 2026. Latest complaint received December 18, 2024.