Recalls apply to specific production ranges. To see whether a particular car still has an open recall, enter its VIN at nhtsa.gov/recalls. Repairs for safety recalls are free at authorised dealers.
2011 Toyota RAV4 recalls
Suspension: rear
NHTSA campaign 16V596000 · reported August 12, 2016 · Toyota Motor Engineering & Manufacturing · 337,449 vehicles potentially affected
- The problem
- Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
- The risk
- Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
- The fix
- Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Seats: front assembly, seat heater/cooler
NHTSA campaign 16V396000 · reported June 2, 2016 · Southeast Toyota Distributors, LLC · 7,749 vehicles potentially affected
- The problem
- Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
- The risk
- If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
- The fix
- SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Seat belts: rear/other
NHTSA campaign 16V096000 · reported February 19, 2016 · Toyota Motor Engineering & Manufacturing · 1,123,752 vehicles potentially affected
- The problem
- Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
- The risk
- A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
- The fix
- Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Visibility: power window devices and controls
NHTSA campaign 15V689000 · reported October 22, 2015 · Toyota Motor Engineering & Manufacturing · 1,814,284 vehicles potentially affected
- The problem
- Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
- The risk
- If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
- The fix
- Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Visibility/wiper
NHTSA campaign 15V577000 · reported September 18, 2015 · Toyota Motor Engineering & Manufacturing · 423,456 vehicles potentially affected
- The problem
- Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2009-2012 RAV4 vehicles manufactured October 27, 2008, to December 19, 2012 and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the affected vehicles, water may drip onto the joint that connects the wiper linkage to the wiper motor.
- The risk
- Over time, the dripping water may cause corrosion and wear at the joint, potentially resulting in the separation of the wiper linkage. Once this occurs, the wipers would not function, reducing driver visibility and increasing the risk of a crash.
- The fix
- Toyota will notify owners, and dealers will replace the water diverter channel. In addition, a new wiper linkage with a wiper motor crank arm will be installed. The wiper linkage will have a protective cover over the wiper linkage joint to minimize water splash and a retainer ring to prevent the wiper arm from separating from the wiper motor. The recall began on November 7, 2016. Owners may contact Toyota's customer service number at 1-800-331-4331.
Seats: front assembly, seat heater/cooler
NHTSA campaign 14V743000 · reported November 19, 2014 · Southeast Toyota Distributors, LLC · 3,233 vehicles potentially affected
- The problem
- Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
- The risk
- Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
- The fix
- SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Suspension: rear
NHTSA campaign 13V383000 · reported August 28, 2013 · Toyota Motor Engineering & Manufacturing · 780,584 vehicles potentially affected
- The problem
- Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
- The risk
- Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
- The fix
- Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
Equipment: other, labels
NHTSA campaign 13V123000 · reported April 9, 2013 · Southeast Toyota Distributors, LLC · 7,525 vehicles potentially affected
- The problem
- Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."
- The risk
- An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.
- The fix
- Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Seats · Air bags: frontal, sensor/control module-inactive
NHTSA campaign 13V014000 · reported January 16, 2013 · Southeast Toyota Distributors, LLC · 3,235 vehicles potentially affected
- The problem
- Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
- The risk
- If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
- The fix
- Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.
Suspension: rear
NHTSA campaign 12V373000 · reported August 2, 2012 · Toyota Motor Engineering & Manufacturing · 780,584 vehicles potentially affected
- The problem
- Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
- The risk
- Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
- The fix
- Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
Air bags: side/window
NHTSA campaign 12V029000 · reported February 1, 2012 · Toyota Motor Engineering & Manufacturing · 427 vehicles potentially affected
- The problem
- Toyota is recalling certain model year 2011 rav4 vehicles, manufactured from november 24, 2011, through december 19, 2011. In the curtain shield airbags, propellant with the incorrect specification was used for the initiator assembled in the airbag inflator. In this condition, the inflator may not perform properly, causing one or both curtain shield airbags to not deploy.
- The risk
- In the event of a crash, the airbags may not deploy and will not be able to properly protect an occupant, increasing the risk of injuries.
- The fix
- Toyota will notify owners, and dealers will check the vehicle identification number to identify the curtain shield assemblies and replace the assemblies as necessary with new ones free of charge. The safety recall began on march 8, 2012. Owners may contact toyota at 1-800-331-4331.
What owners report
Recent complaints filed with NHTSA, shortened. These are unverified accounts from owners, not findings.
Jul 13, 2026 · Air bags
Airbag light is on
Apr 10, 2026 · Electrical system · 230,000 miles
Odometer Fraud. The contact purchased a 2011 Toyota Rav4. The contact discovered that there was a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the mileage was 89,000. It was later discovered upon checking the Carfax report that the mileage was 230,000.
Apr 3, 2026 · Suspension · 195,000 miles
The contact owns a 2011 Toyota Rav4. The contact stated that while driving at various speeds, there was an abnormal clunking sound coming from the rear end of the vehicle. The contact stated that the vehicle felt as if the rear suspension had failed. The vehicle was taken to a certified mechanic, who determined that…
Feb 24, 2026 · Vehicle speed control · 135,000 miles
The contact owns a 2011 Toyota Rav4. The contact stated that while driving and depressing the brake pedal to come to a complete stop, the vehicle continued to accelerate unintendedly. The contact continuously depressed the brake pedal and shifted to neutral(N), and the vehicle responded as intended. The contact stated…
Feb 19, 2026 · Structure
I bought a pre-own car for my daughter in November 2022 from CARMAX in the City of Colma, California. The car is white color 2011 Toyota Rav4. In March 2025, my daughter started noticing the paint peeling off from the roof and driver side front panel. I found out that the paint issue is due to the defects from…
Source: NHTSA recall and complaint data, updated October 27, 2026. Latest complaint received July 13, 2026.