Does the 2007 Volvo XC90 have any recalls?

Yes. NHTSA lists 2 recalls for the 2007 Volvo XC90, the most recent reported on November 8, 2010 (Equipment: electrical, navigational system(global positioning system)). Check a specific car by its VIN at nhtsa.gov/recalls.

What are the most common problems with the 2007 Volvo XC90?

Owners have filed 38 complaints with NHTSA. The most frequently reported area is electrical system (14 complaints), followed by power train (5).

How many 2007 Volvo XC90 complaints mention a crash or fire?

0 of 38 complaints report a crash and 5 a fire; 0 injuries were reported in total. Complaints are unverified reports from owners.

2007 Volvo XC90 recalls and problems

2 recalls and 38 owner complaints on file with NHTSA for the 2007 Volvo XC90.

recalls

owner complaints

complaints mentioning a crash

mentioning a fire

Recalls apply to specific production ranges. To see whether a particular car still has an open recall, enter its VIN at nhtsa.gov/recalls. Repairs for safety recalls are free at authorised dealers.

2007 Volvo XC90 recalls

Equipment: electrical, navigational system(global positioning system)

NHTSA campaign 10V566000 · reported November 8, 2010 · VOLVO CARS OF N.A. LLC. · 416 vehicles potentially affected

The problem: Volvo is recalling certain vehicles equipped with garmin 760 portable global positioning system (gps) units because the batteries on those units may overheat.
The risk: An overheated battery could lead to a fire.
The fix: Volvo advises owners to please stop using the garmin portable gps device immediately, and visit the garmin website to determine if their unit is affected. The unit's battery will be replaced with a new battery and a spacer will be inserted on top of the battery next to the pcb. This service will be performed free of charge. The safety recall began on november 18, 2010. Owners may contact garmin at 866-957-1981 or visit garmin's website at www.garmin.com/nuvibatterypcbrecall.

Visibility: defroster/defogger/hvac system

NHTSA campaign 07V563000 · reported December 12, 2007 · VOLVO CARS OF N.A. LLC. · 37,000 vehicles potentially affected

The problem: On certain sport utility vehicles, under certain conditions, the climate control module (ccm) may receive a 'shut-down signal' from the engine control module (ECM) after ignition key insertion. If this condition occurs, the climate control functions will not be available (including the defroster) during that driving cycle.
The risk: Inoperative defrosters under inclement weather conditions could cause impaired visibility which has the potential to result in personal injury and/or vehicle and property damage.
The fix: The ECM software will be upgraded. The recall began on january 28, 2008. Owners may contact volvo at 1-800-458-1552.

Most reported problems

Areas named in owner complaints to NHTSA. One complaint can name several areas.

Electrical system14
Power train5
Engine4
Steering4
Unknown or other4
Exterior lighting3
Fuel/propulsion system3
Suspension3
Electronic stability control (ESC)2
Engine and engine cooling2

What owners report

Recent complaints filed with NHTSA, shortened. These are unverified accounts from owners, not findings.

Feb 2, 2026 · Electrical system · fire reported
While driving the vehicle under normal conditions, a sudden electrical fire occurred, requiring immediate evacuation. The vehicle was pulled over safely and the driver exited before the fire escalated. The fire department responded and the vehicle was declared a total loss due to fire damage. The failure is believed…

Dec 29, 2023 · Air bags · 80,000 miles
The contact owns a 2007 Volvo XC90. The contact stated that the air bag warning light was illuminated on the instrument cluster. The local dealer was contacted, and it was diagnosed that the failure was due to the air bag module. The vehicle was repaired, but the failure recurred. The vehicle was taken to an…

Nov 27, 2023 · Fuel/propulsion system
I am writing to bring to your attention a concerning matter regarding my recently acquired 2007 Volvo XC90. Upon refueling the vehicle to a level exceeding half the tank capacity, there is a discernible and persistent odor of gasoline within the cabin. Given the potential safety implications associated with such an…

Sep 2, 2023 · Fuel/propulsion system
Drivers side fuel tank sending unit print or sending unit top leaking fuel, a check engine light appeared and almost instantly started smelling like gas. The check engine said small evap leak. This is a huge safety concern for my family and I. No further action has been done.

Dec 13, 2022 · Fuel/propulsion system
IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE. This Recall Was Done for a 2004 Volvo xc90 . I am currently Experiencing the same problem with my 2007 volvo Xc90 AWD. Every time, I fill up to 1/2 a tank or full , I…

XC90 model years compared

Year	Recalls	Complaints	Crashes	Fires
2004	6	462	9	3
2005	6	223	1	3
2006	3	53	4	4
2007	2	38	0	5
2008	3	29	1	1
2009	1	7	0	0
2010	3	12	0	0

Across all years, the 2004 XC90 has the most complaints (462). All Volvo XC90 years →

Questions

Does the 2007 Volvo XC90 have any recalls?: Yes. NHTSA lists 2 recalls for the 2007 Volvo XC90, the most recent reported on November 8, 2010 (Equipment: electrical, navigational system(global positioning system)). Check a specific car by its VIN at nhtsa.gov/recalls.
What are the most common problems with the 2007 Volvo XC90?: Owners have filed 38 complaints with NHTSA. The most frequently reported area is electrical system (14 complaints), followed by power train (5).
How many 2007 Volvo XC90 complaints mention a crash or fire?: 0 of 38 complaints report a crash and 5 a fire; 0 injuries were reported in total. Complaints are unverified reports from owners.

Source: NHTSA recall and complaint data, updated October 27, 2026. Latest complaint received February 2, 2026.