Recalls apply to specific production ranges. To see whether a particular car still has an open recall, enter its VIN at nhtsa.gov/recalls. Repairs for safety recalls are free at authorised dealers.
2000 Chevrolet Tahoe recalls
Service brakes, hydraulic: antilock/traction control/electronic limited slip
NHTSA campaign 05V379000 · reported August 29, 2005 · GENERAL MOTORS CORP. · 1,353,718 vehicles potentially affected
- The problem
- Certain pickup trucks and sport utility vehicles may experience unwanted antilock brake system (ABS) activation. This condition is more likely to occur in environmentally corrosive areas. This recall will be launched in the "salt belt" states of connecticut, delaware, illinois, indiana, iowa, maryland, massachusetts, maine, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin and the district of columbia only.
- The risk
- This can cause increased stopping distances during low-speed brake applications, which could result in a crash.
- The fix
- Dealers are to remove the wheel speed sensor and thoroughly clean the wheel speed sensor mounting surface on the bearing, apply rust inhibitor to the cleaned surface, grease the mounting surface, reinstall the wheel speed sensor, and check the peak-to-peak output voltage to ensure the wheel speed signal is within specifications. The recall began september 22, 2005. Owners may contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.
Structure
NHTSA campaign 03V094000 · reported March 7, 2003 · SOUTHERN COMFORT CONVERSIONS · 3,674 vehicles potentially affected
- The problem
- Certain pickup truck, van, and mini van conversions equipped with southern comfort built running boards that contain certain courtesy lights manufactured by american technology components, INC. These units contain a courtesy light or lights that might overheat when the wire harness is exposed to excessive moisture and road salt.
- The risk
- This overheating condition can cause the running board to melt or cause a fire.
- The fix
- Dealers will replace the wiring harness on these running boards. Owner notification began march 7, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact southern comfort at 1-800-745-6096.
Seats: front assembly, head restraint
NHTSA campaign 02V253000 · reported September 17, 2002 · GENERAL MOTORS CORP. · 558,904 vehicles potentially affected
- The problem
- On certain sport utility vehicles equipped with rearward folding head restraints on the second row seats, two potential pinch points exist on each of the folding head restraints when the restraints are folded rearward as the seatback is folded down.
- The risk
- If a person were to insert their finger(s) into the pinch point when the head restraint folds, it could trap and pinch the finger(s) causing injury.
- The fix
- Dealers will install protective covers over the pinch points. Owner notification began november 8, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, gmc at 1-800-462-8782, or cadillac at 1-800-458-8006.
Air bags: frontal, sensor/control module-inactive
NHTSA campaign 02V178000 · reported July 1, 2002 · GENERAL MOTORS CORP. · 525,254 vehicles potentially affected
- The problem
- On certain pickup and utility trucks, some of these vehicles have an air bag sensing diagnostic module (sdm) which contains an anomaly that could result in the driver and passenger's air bag failing to deploy during certain frontal crashes.
- The risk
- In a vehicle crash, front seat occupants may receive more severe injuries.
- The fix
- Dealers will recalibrate the sdm on the affected vehicles. Owner notification began august 28, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.
Service brakes, hydraulic: foundation components, hoses, lines/piping, and fittings
NHTSA campaign 00V345000 · reported October 30, 2000 · GENERAL MOTORS CORP. · 1,383,922 vehicles potentially affected
- The problem
- Vehicle description: light duty pickup trucks and sport utility vehicles. Some of these vehicles have a clearance condition between the front right-hand brake pipe and the body cross sill that could decrease to the point of allowing contact during the life of the vehicle. If contact occurs and the brake pipe becomes damaged, in half of the brake system there can be a loss of brake fluid and pressure. The brake warning lamp will be activated when the brake fluid level reaches the indicator limit.
- The risk
- During braking, the pedal will be lower than normal and stopping distances will be longer. If this occurs when stopping distance is limited, a crash could occur.
- The fix
- Dealers will inspect the front right-hand brake pipe for wear. If there are signs of wear, this section of the brake pipe will be replaced with a new designed brake pipe section. If there are not signs of wear on the brake pipe, the dealer will install a spacer clip to ensure sufficient clearance between the brake pipe and the body cross sill.
Structure: body
NHTSA campaign 00V343000 · reported October 25, 2000 · GENERAL MOTORS CORP. · 35,659 vehicles potentially affected
- The problem
- Vehicle description: light duty pickup trucks and sport utility vehicles. Some of these vehicles have loose or missing rear wheelhouse plugs. Under certain vehicle operating conditions, exhaust gases can flow forward and accumulate in the rear wheelhouse.
- The risk
- These gases could flow into the passenger compartment if the plug is missing or loose and could cause possible illness, unconsciousness, or death.
- The fix
- Dealers will inspect the vehicle for loose or missing wheelhouse plugs and install new plugs if necessary.
What owners report
Recent complaints filed with NHTSA, shortened. These are unverified accounts from owners, not findings.
Mar 14, 2025 · Tires · crash reported
See attached document for complaint
Jul 30, 2023 · Service brakes · fire reported
The ABS caught on fire. Lost brakes and all brake fluid, no police reports because it was in my alley way as soon as I started moving, when it happened the ABS and brake lights both came on at the same time. No prior warning.
Mar 17, 2023 · Service brakes, hydraulic · 150,000 miles
The contact owns a 2000 Chevrolet Tahoe. The contact stated that while driving at slow speeds, the ABS would erroneously activate. During the failure, the stopping distance was increased and the ABS warning light was activated. The cause of the failure was not yet determined. The manufacturer was notified of the…
Feb 25, 2022 · Service brakes
ABS/Traction Control wheel speed sensors corroded, causing the ABS to activate at low speeds and making it impossible to stop the car. This is the same issue as has been reported for other VIN numbers of the same vehicle; see Safety Recall 05068 Front Wheel Speed Sensor Corrosion…
Aug 20, 2019 · Service brakes · 166,000 miles · crash reported
TL* THE CONTACT OWNS A 2000 CHEVROLET TAHOE. THE CONTACT STATED THAT WHEN HIS DAUGHTER DROVE DOWN HILL AND THE BRAKE PEDAL WAS ENGAGED, THE BRAKE SYSTEM FAILED TO ENGAGE CAUSING THE DRIVER TO HIT A PERSON THAT WAS DRIVING A BICYCLE. THE VEHICLE WENT UP A HILL AND THE DRIVER PROCEEDED ATTEMPTING TO STOP THE VEHICLE BUT…
Source: NHTSA recall and complaint data, updated October 27, 2026. Latest complaint received March 14, 2025.