Recalls apply to specific production ranges. To see whether a particular car still has an open recall, enter its VIN at nhtsa.gov/recalls. Repairs for safety recalls are free at authorised dealers.
2006 Toyota RAV4 recalls
Suspension: rear
NHTSA campaign 16V596000 · reported August 12, 2016 · Toyota Motor Engineering & Manufacturing · 337,449 vehicles potentially affected
- The problem
- Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
- The risk
- Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
- The fix
- Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Seats: front assembly, seat heater/cooler
NHTSA campaign 16V396000 · reported June 2, 2016 · Southeast Toyota Distributors, LLC · 7,749 vehicles potentially affected
- The problem
- Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
- The risk
- If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
- The fix
- SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Seat belts: rear/other
NHTSA campaign 16V096000 · reported February 19, 2016 · Toyota Motor Engineering & Manufacturing · 1,123,752 vehicles potentially affected
- The problem
- Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
- The risk
- A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
- The fix
- Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.
Visibility: power window devices and controls
NHTSA campaign 15V689000 · reported October 22, 2015 · Toyota Motor Engineering & Manufacturing · 1,814,284 vehicles potentially affected
- The problem
- Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
- The risk
- If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
- The fix
- Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Air bags: frontal, driver side, inflator module
NHTSA campaign 14V168000 · reported April 9, 2014 · Toyota Motor Engineering & Manufacturing · 1,486,413 vehicles potentially affected
- The problem
- Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
- The risk
- If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
- The fix
- Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Suspension: rear
NHTSA campaign 13V383000 · reported August 28, 2013 · Toyota Motor Engineering & Manufacturing · 780,584 vehicles potentially affected
- The problem
- Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
- The risk
- Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
- The fix
- Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from September 2013 through mid-April 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. IMPORTANT: This recall supersedes Toyota and Lexus recall 12V-373. All vehicles that have been inspected and remedied under the previous recall need to be re-inspected and have the appropriate remedy applied.
Suspension: rear
NHTSA campaign 12V373000 · reported August 2, 2012 · Toyota Motor Engineering & Manufacturing · 780,584 vehicles potentially affected
- The problem
- Toyota is recalling certain model year 2006 through 2011 RAV4 and 2010 Lexus HS250h passenger vehicles manufactured from October 2005 through September 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
- The risk
- Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
- The fix
- Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on November 30, 2012. Owners may contact Toyota at 1-800-331-4331 or Lexus at 1-800-255-3987.
Vehicle speed control: accelerator pedal
NHTSA campaign 11V113000 · reported February 24, 2011 · TOYOTA MOTOR NORTH AMERICA, INC. · 1,363,244 vehicles potentially affected
- The problem
- Toyota is recalling certain model year 2008 through 2011 lexus lx570, 2003 through 2009 toyota 4runner, and 2006 through 2010 rav4 vehicles. The accelerator pedal can get stuck in the wide open position due to its being trapped by an unsecured or incompatible driver's floor mat.
- The risk
- A stuck open accelerator pedal may result in very high vehicle speeds and make it difficult to stop the vehicle, which could cause a crash, serious injury or death.
- The fix
- The remedy is now available. The safety recall began early april 2011. The remedy will involve modification or replacement of the accelerator pedal and replacement of any toyota all-weather floor mat. Owners may contact toyota at 1-800-331-4331 or lexus at 1-800-255-3987.
Equipment: other, labels
NHTSA campaign 10V035000 · reported February 3, 2010 · GULF STATES TOYOTA, INC. · 271,417 vehicles potentially affected
- The problem
- Gulf states toyota is recalling certain model year 2005-2010 vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold between september 1, 2005 and june 2, 2008 without the requisite load carrying capacity modification labels.
- The risk
- This does not meet the standard requirements.
- The fix
- Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. Dealers will also correct the owner's manual. The safety recall began on may 27, 2010. Owners may contact gulf states toyota at 713-580-3300.
Equipment: other, labels
NHTSA campaign 10V036000 · reported February 3, 2010 · SOUTHEAST TOYOTA DISTRIBUTORS, LLC · 153,418 vehicles potentially affected
- The problem
- Southeast toyota is recalling certain model year 2005-2011 passenger vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold without the requisite load carrying capacity modification labels.
- The risk
- A driver may overload a vehicle which may increase the risk of a crash.
- The fix
- Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. The safety recall began on may 27, 2010. Owners may contact southeast toyota at 1-800-301-6859.
Equipment: other, labels
NHTSA campaign 09V223000 · reported June 15, 2009 · TOYOTA MOTOR NORTH AMERICA, INC. · 27,080 vehicles potentially affected
- The problem
- Toyota is recalling 27,080 model year 2005 through 2010 passenger cars built from september 1, 2005 to may 4, 2009. These vehicles were not equipped with load carrying capacity modification labels which fails to conform with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims."
- The risk
- Incorrect load carrying capacity modification labels could result in the vehicle being overloaded, increasing the risk of a crash.
- The fix
- Toyota will notify owners and provide them with a new, accurate label to be installed over the inaccurate label free of charge. The safety recall began on august 18, 2009. Owners may contact toyota at 1-888-270-9371.
What owners report
Recent complaints filed with NHTSA, shortened. These are unverified accounts from owners, not findings.
Sep 26, 2026 · Structure
2016 Superseding Recall (Campaign 16V596000): Toyota issued a follow-up recall because some initial epoxy repairs were not enough. Dealers must replace both rear suspension arms and encapsulate the locknuts completely free of charge. These parts are severely rusted and corroded on my 2006 Toyota Rav4. It seems like my…
Mar 13, 2026 · Electrical system · 199,694 miles
Odometer Fraud. The contact purchased a 2006 Toyota Rav4. The contact discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 122,000, and at the time of registration, it was discovered that the mileage was 199,694.
Oct 30, 2025 · Suspension
My 2006 Toyota RAV4 was supposedly repaired under the rear suspension arm recall (C0J / G0V), but the rear tie rod ends still have yellow stickers reading “this is a recalled part” and no epoxy on the bolts. A Toyota dealer refused to inspect the vehicle and relied solely on the VIN record. The car now rides roughly…
Aug 9, 2025 · Steering
For several months the 2006 Rav4 with only 118k miles had been experiencing intermittent failure of power steering while driving at speeds between 5-20mph. These failures resulted in the steering wheel to become extremely difficult if not impossible to turn while the car is driving. In each incident, this resulted in…
Mar 31, 2025 · Structure
Rear subframe rusted out. I took it in because my car started sounding like the Titanic after it hit an iceberg. The mechanic described it as “a giant hole in the bottom of the car.” I read there were recalls on frames for other Toyotas, but we kept up with every recall on this vehicle and the subframe was never…
Source: NHTSA recall and complaint data, updated October 27, 2026. Latest complaint received September 26, 2026.