CarRecallDB

2007 Volvo S40 recalls and problems

2 recalls and 25 owner complaints on file with NHTSA for the 2007 Volvo S40.

2
recalls
25
owner complaints
4
complaints mentioning a crash
1
mentioning a fire

Recalls apply to specific production ranges. To see whether a particular car still has an open recall, enter its VIN at nhtsa.gov/recalls. Repairs for safety recalls are free at authorised dealers.

2007 Volvo S40 recalls

Equipment: electrical, navigational system(global positioning system)

NHTSA campaign 10V566000 · reported November 8, 2010 · VOLVO CARS OF N.A. LLC. · 416 vehicles potentially affected

The problem
Volvo is recalling certain vehicles equipped with garmin 760 portable global positioning system (gps) units because the batteries on those units may overheat.
The risk
An overheated battery could lead to a fire.
The fix
Volvo advises owners to please stop using the garmin portable gps device immediately, and visit the garmin website to determine if their unit is affected. The unit's battery will be replaced with a new battery and a spacer will be inserted on top of the battery next to the pcb. This service will be performed free of charge. The safety recall began on november 18, 2010. Owners may contact garmin at 866-957-1981 or visit garmin's website at www.garmin.com/nuvibatterypcbrecall.

Service brakes, hydraulic: foundation components, master cylinder

NHTSA campaign 08V101000 · reported March 5, 2008 · VOLVO CARS OF N.A. LLC. · 1,114 vehicles potentially affected

The problem
Volvo is recalling 1,114 my 2007 c30, c70, s40, and v50 passenger vehicles. A soft anodized layer in the master cylinder may trigger early wear on a rubber seal that can result in internal leakage of brake fluid. If affected, the driver may experience reduced brake performance when applying and maintaining force of the brake pedal.
The risk
The capacity to brake will gradually deteriorate forcing the driver to use a higher than expected force on the brake pedal when compared to an intact brake system. The deterioration can eventually result in complete loss of the brake system functionality increasing the risk of a crash.
The fix
Dealers will inspect the master cylinder. The brake master cylinder and brake fluid reservoir will be replaced and certain brake lines cleaned free of charge. The recall began on march 11, 2008. Owners may contact volvo at 1-800-458-1552.

Most reported problems

Areas named in owner complaints to NHTSA. One complaint can name several areas.

What owners report

Recent complaints filed with NHTSA, shortened. These are unverified accounts from owners, not findings.

Sep 22, 2020 · Electrical system · 99,000 miles

ON OR ABOUT 12/04/2019 DURING A FLASH RAIN STORM LAST WINTER, MY HUSBAND AND I WAS HEADED HOME ON THE 215 FWY NORTHBOUND IN SAN BERNARDINO, CA WHEN THE CENTER DOME AREA AND THE ELECTRIC SUNROOF INSIDE OUR CAR BEGIN POURING IN HUGE AMOUNTS OF VERY COLD RAIN WATER ON US AND ON THE DASHBOARD, STEREO CONSOLE, GEAR…

May 6, 2019 · Steering · 124,000 miles

I WAS DRIVING AND THE ENGINE SHUT OFF CAUSING ME TO LOSE CONTROL OF MY VEHICLE AS THE POWER STEERING SHUT DOWN. I WAS ABLE TO STEER MY VEHICLE WITH DIFFICULTY TO THE SIDE OF THE ROAD WHERE IT STOPPED. ABOUT ONE WEEK LATER THIS HAPPENED AGAIN. THIS TIME I WAS COMING OUT OF A PARKING LOT AND HAD TO AIM MY VEHICLE IN A…

Oct 19, 2018 · Seat belts · 60,000 miles · crash reported

TL* THE CONTACT OWNED A 2007 VOLVO S40. THE CONTACT CALLED ON BEHALF OF THE DRIVER. THE CONTACT STATED THAT THE VEHICLE WAS STRUCK ON THE FRONT PASSENGER SIDE BY ANOTHER VEHICLE. THE SPEED WAS UNKNOWN. THE AIR BAG FAILED TO DEPLOY AND THE SEAT BELT DETACHED. THE DRIVER SUSTAINED LEG, BACK, AND SHOULDER INJURIES THAT…

May 31, 2018 · Electronic stability control (ESC) · 104,000 miles

AFTER PARKING CAR AND TURNING CAR OFF, AIRBAG, BRAKE, AND INFORMATION WARNING LIGHTS STAY ON, AS DOES VENTILATION SYSTEM. PASSENGER SEAT HAS EXCESS WATER UNDERNEATH. NOW CAR WILL NOT START.

Feb 2, 2017 · Vehicle speed control · 10 miles

VEHICLE LOSES POWER DUE TO ACCELERATOR PEDAL LOW VOLTAGE/SIGNAL. THIS OCCURS IN MULTIPLE SITUATIONS. SAFEST IS SHORTLY AFTER STARTING THE CAR AN ENGINE LIGHT STATING 'ENGINE SYSTEM URGENT' APPEARS. UNSAFE OCCURRENCE INCLUDES POWER LOSS WHILE PEDAL IS DEPRESSES SUCH AS ON THE HIGHWAY WITH CONSTANT PRESSURE OR MOST…

S40 model years compared

YearRecallsComplaintsCrashesFires
2004 64851
2005 36920
2006 35810
2007 22541
2008 21650
2009 31003
2010 2910

Across all years, the 2000 S40 has the most complaints (122). All Volvo S40 years →

Questions

Does the 2007 Volvo S40 have any recalls?
Yes. NHTSA lists 2 recalls for the 2007 Volvo S40, the most recent reported on November 8, 2010 (Equipment: electrical, navigational system(global positioning system)). Check a specific car by its VIN at nhtsa.gov/recalls.
What are the most common problems with the 2007 Volvo S40?
Owners have filed 25 complaints with NHTSA. The most frequently reported area is electrical system (5 complaints), followed by service brakes, hydraulic (4).
How many 2007 Volvo S40 complaints mention a crash or fire?
4 of 25 complaints report a crash and 1 a fire; 5 injuries were reported in total. Complaints are unverified reports from owners.

Source: NHTSA recall and complaint data, updated October 27, 2026. Latest complaint received September 22, 2020.