Recalls apply to specific production ranges. To see whether a particular car still has an open recall, enter its VIN at nhtsa.gov/recalls. Repairs for safety recalls are free at authorised dealers.
2003 Volvo S60 recalls
Air bags: frontal, driver side, inflator module
NHTSA campaign 21V766000 · reported September 30, 2021 · Volvo Car USA, LLC · 259,383 vehicles potentially affected
- The problem
- Volvo Car USA, LLC (Volvo Car) is recalling certain 2001-2006 S80 and 2001-2009 S60 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
- The risk
- An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
- The fix
- Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed November 29, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo's number for this recall is R10125.
Air bags: frontal, driver side, inflator module
NHTSA campaign 20V681000 · reported November 4, 2020 · Volvo Car USA LLC · 54,124 vehicles potentially affected
- The problem
- Volvo Car USA LLC (Volvo Car) is recalling certain 2001-2003 S80 and S60 vehicles sold or ever registered in Alabama, Arkansas, Florida, Georgia, Hawaii, Louisiana, Mississippi, North Carolina, Oklahoma, South Carolina, Tennessee, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. The driver side frontal air bag inflator may rupture, sending metal fragments into the passage compartment, when the driver side air bag is deployed.
- The risk
- Metal fragments can strike vehicle occupants increasing the risk of serious injury or death.
- The fix
- Volvo Car will notify owners, and dealers will replace the driver side air bag module, free of charge. The recall began April 20, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10058.
Equipment: electrical, navigational system(global positioning system)
NHTSA campaign 10V566000 · reported November 8, 2010 · VOLVO CARS OF N.A. LLC. · 416 vehicles potentially affected
- The problem
- Volvo is recalling certain vehicles equipped with garmin 760 portable global positioning system (gps) units because the batteries on those units may overheat.
- The risk
- An overheated battery could lead to a fire.
- The fix
- Volvo advises owners to please stop using the garmin portable gps device immediately, and visit the garmin website to determine if their unit is affected. The unit's battery will be replaced with a new battery and a spacer will be inserted on top of the battery next to the pcb. This service will be performed free of charge. The safety recall began on november 18, 2010. Owners may contact garmin at 866-957-1981 or visit garmin's website at www.garmin.com/nuvibatterypcbrecall.
Fuel system, gasoline: delivery, fuel pump
NHTSA campaign 09V483000 · reported December 18, 2009 · VOLVO CARS OF N.A. LLC. · 158,733 vehicles potentially affected
- The problem
- Volvo is recalling certain model year 2001-2005 s80, model year 2001-2004 v70, s60, xc70 and model year 2003-2005 xc90 vehicles sold in or registered in the states of alabama, arizona, arkansas, california, florida, georgia, hawaii, kentucky, louisiana, mississippi, nevada, new mexico, north carolina, oklahoma, south carolina, tennessee, texas, utah, virginia and the u.s. Territories. When exposed to certain environmental conditions (hot climate and temperature cycling) over time and in combination with varying fuel quality, the fuel pump can develop cracks in the fuel pump flange.
- The risk
- If the condition occurs vehicle owners may notice fuel smell and/or fuel leak which, in the presence of an ignition source, could result in a fire.
- The fix
- Dealers will inspect the fuel pump installed in the vehicle, and if necessary replace the fuel pump with a part of a modified design. This service will be performed free of charge. The safety recall began on january 15, 2010. Owners may contact volvo at 1-800-458-1552.
Engine and engine cooling
NHTSA campaign 07V226000 · reported June 5, 2007 · VOLVO CARS OF N.A. LLC. · 32,189 vehicles potentially affected
- The problem
- On certain passenger vehicles, the fuel pressure sensor located on the left end of the fuel rail may, at times, transmit incorrect signal regarding the fuel pressure to the engine control module. If the signal is outside of the pre-programmed allowable limits, a diagnostic trouble code may be set and the check engine light will come on. The soldered joints on the circuit board of the fuel pressure sensor may crack due to temperature changes and excessive vibrations.
- The risk
- Misfire may occur during driving that, in turn, will reduce the engine torque and in the worst case scenario, the engine may stall without warning. In certain traffic situations this could cause an unsafe situation and possibly a crash.
- The fix
- Dealers will replace the fuel pressure sensor free of charge. The recall began on june 29, 2007. Owners may contact volvo at 1-800-458-1552.
Equipment: other, labels
NHTSA campaign 03V284000 · reported August 1, 2003 · VOLVO CARS OF N.A. LLC. · 220,407 vehicles potentially affected
- The problem
- Certain passenger cars fail to comply with the requirements of federal motor vehicle safety standard no. 225, "child restraint anchorage systems." the second isofix guide was not installed in these vehicles and, in certain cases, the owner's manual isofix information is incorrect.
- The risk
- This does not meet the requirements of the standard.
- The fix
- Owners will receive a letter/package consisting of the second isofix guide with installation instructions, and in certain cases, the corrected owner's manual may be provided. If the owner wants to take their vehicle to a volvo dealer for installation of the guide, it will be performed at no charge to the owner. Owner notification began on december 19, 2003. Owners should contact volvo at 1-800-458-1552.
What owners report
Recent complaints filed with NHTSA, shortened. These are unverified accounts from owners, not findings.
Jan 18, 2026 · Electrical system
The problem is when the weather turns cold my car a Volvo 2003 S 60 turn signals do not operate, or if they do turn on sometimes the turn signals won't stop flashing until you turn the ignition off. The head lights also will not turn on at any setting during this time. When the weather turns warm again everything…
Aug 14, 2020 · Steering · 126,000 miles
TL* THE CONTACT OWN A 2003 VOLVO S60. THE CONTACT STATED THAT THE FRONT STRUTS WERE COMING THROUGH THE STRUT MOUNTS. THE CONTACT STATED THAT THE VEHICLE SHOOK VIOLENTLY WHILE DRIVING. THE CHECK ENGINE WARNING LIGHT AND ANOTHER UNKNOWN WARNING LIGHT WERE ILLUMINATED. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO…
Jun 17, 2020 · Steering
THE STEERING HAS BECOME LESS RESPONSIVE AND I EXPERIENCE STEERING WHEEL PLAY, REPLACING FLUID HAS NOT RESOLVED THIS ISSUE.
May 12, 2019 · Electrical system · 158,000 miles
INSTRUMENT PANEL/CLUSTER GOES OUT WHILE DRIVING WHICH MEANS YOU CAN'T READ ANY OF THE GUAGES OR WARNINGS LIGHTS OTHER THAN IF CHECK ENGINE LIGHT IS ON. THIS IMPOSES A SAFETY RISKS TO ME AND OTHER TRAFFIC ON THE ROAD. IT DOES THIS ERRATICALLY, GOING OUT COMPLETELY AND COMING BACK ON IN TIME. NO FUSE PROBLEMS, THEY ARE…
Sep 24, 2018 · Fuel/propulsion system
VECHILE LEAKING GAS AND HAD STRONG GAS SMELL.
Source: NHTSA recall and complaint data, updated October 27, 2026. Latest complaint received January 18, 2026.