Recalls apply to specific production ranges. To see whether a particular car still has an open recall, enter its VIN at nhtsa.gov/recalls. Repairs for safety recalls are free at authorised dealers.
2002 Ford E-350 recalls
Vehicle speed control
NHTSA campaign 09V399000 · reported October 13, 2009 · FORD MOTOR COMPANY · 4,500,000 vehicles potentially affected
- The problem
- Ford is recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 f-250 sd through f-550 sd diesel, 1992-2003 e-150 through e-550, 1995-2002 explorer, 1997 and 2002 mercury mountaineer, 1995-1997 and 2001-2003 ranger, and 1994 f53 vehicles equipped with the texas instruments speed control deactivation switch (scds). The scds may leak internally and then overheat, smoke, or burn.
- The risk
- A vehicle fire could occur with or without the engine running.
- The fix
- Ford will notify owners that dealers will install a fused wiring harness in line with the scds. On 1999-2003 windstar vehicles with a leaking scds, dealers will also inspect the ABS control module connector and repair as necessary. Repairs will be completed free of charge. The safety recall began on october 27, 2009. Owners may contact ford at 1-888-222-2751.
Vehicle speed control: cruise control
NHTSA campaign 08V051000 · reported February 4, 2008 · FORD MOTOR COMPANY · 225,000 vehicles potentially affected
- The problem
- Ford is recalling 225,000 my 1992-2003 econoline, my 1993-1995 taurus sho, my 1992-1998 crown victoria, my 1993 bronco, f-series, my 1995-1997 f-series super duty stripped chassis, my 1992-1998 mercury grand marquis, and my 1992-1995 lincoln town car vehicles. The affected vehicles were previously repaired using a wiring harness that is not compatible with the vehicle circuit polarity.
- The risk
- As a result, the fuse is located in the output circuit rather than in the intended input power feed circuit, and may not offer the intended protection in the event of an electrical short to ground.
- The fix
- Dealers will install a new wiring harness, or replace the mating electrical component. The recall began on february 18, 2008. Owners may contact ford at 1-800-392-3673.
Vehicle speed control
NHTSA campaign 07V336000 · reported August 3, 2007 · FORD MOTOR COMPANY · 3,600,000 vehicles potentially affected
- The problem
- On certain pickup trucks, passenger vehicles, sport utility vehicles, and motor homes chassis, the speed control deactivation switch may, under certain conditions, leak internally and then overheat, smoke, or burn.
- The risk
- This could result in an underhood fire.
- The fix
- Dealers will install a fused wiring harness. Owners of the passenger cars included in this campaign will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected as an interim repair. As soon as repair parts are available (expected october 2007), owners will be instructed to return to the dealers for installation of a fused wiring harness. The recall began on august 13, 2007, and mailing completed by september 19, 2007. Owners may contact ford at 1-888-222-2751.
Equipment adaptive/mobility
NHTSA campaign 04V589000 · reported December 15, 2004 · ACCUBUILT, INC. · 501 vehicles potentially affected
- The problem
- On certain vans built on ford e250/e350 chassis and equipped with sure-lok wheelchair securement systems, the sprocket teeth of the retractor assembly is out of alignment.
- The risk
- In the event of a vehicle crash, the wheelchair may not be adequately secured possibly resulting in injuries to a wheelchair occupant.
- The fix
- Dealers will inspect and replace the wheelchair securement retractors as necessary. Sure-lok is conducting the owner notification and remedy for this campaign. Owners should contact sure-lock at 1-908-231-1804 or accubuilt at 419-222-1501.
Equipment: other, labels
NHTSA campaign 04V232000 · reported May 13, 2004 · FORD MOTOR COMPANY · 28,456 vehicles potentially affected
- The problem
- Certain vans and wagons fail to conform to the requirements of part 567, "certification." for certain 2003 e250 vans built with lt225/75r16e tires, the rear axle rating is incorrectly listed on the label. In addition, the tire pressure is incorrectly listed on the label for the rear tires on certain 2002 e350 wagons and for the front tires on certain 2002 e250 vans built with these tires.
- The risk
- Failure to follow proper vehicle loading specifications or tire inflation recommendation can result in tire failure, increasing the risk of a crash.
- The fix
- Owners will be provided with supplementary tire labels containing correct information and installation instructions. If an owner so desires, their dealer can install the label for them. The recall began on july 8, 2004. Owners should contact ford at 1-800-392-3673.
What owners report
Recent complaints filed with NHTSA, shortened. These are unverified accounts from owners, not findings.
Sep 6, 2018 · Engine · 114,000 miles
HEAD ON VEHICLE STRIPPED BECAUSE OF THE WAY IT IS MADE. THERE WAS A RECALL ON REGULAR E350 BUT MINE IS AN RV. IT WAS IN MOTION WHEN THE SPARK PLUG POPPED OUT WHILE DRIVING DOWN THE HIGHWAY ON I-65 IN BIRMINGHAM ALABAMA.
Sep 26, 2017 · Engine
THIS 350 ECONOLINE, 8CYL., EXTENDED BODY VAN WAS PURCHASED NEW, AND I AM THE ORIGINAL OWNER. THE VEHICLE HAS ONLY 120K MILES ON IT SINCE 2002. BEGINNING SEVERAL YEARS AGO, MY MECHANIC COMPLAINED OF SEVERE FRAME EROSION, HAVING HAD TO REINFORCE AND RE-WELD SEVERAL PARTS BACK ONTO THE FRAME, INCLUDING BUT NOT LIMITED TO…
Feb 27, 2017 · Fuel/propulsion system · 120,000 miles
BLOWING OUT SPARK PLUGES.
Aug 31, 2015 · Fuel/propulsion system · 240,000 miles
WHILE TRAVELING ON AN INTERSTATE HIGHWAY, THE VAN STARTED SHOWING SYMPTOMS OF FUEL STARVATION AND WITH THE FAMILY AND A SEMI ON MY BUMPER THINGS GOT QUITE HAIRY AND STARTED AND ARGUMENT WITH MY WIFE! I EXITED THE HIGHWAY AND PUT CLEAN DIESEL FUEL AND FUEL ADDITIVE TO GET ME BACK HOME; THIS DID NOT WORK AS THE VAN…
Jul 15, 2015 · Tires · 108,362 miles
TL* THE CONTACT OWNS A 2002 FORD E-350 EQUIPPED WITH MICHELIN LT24575R16 TIRES, SIZE: 245/756/16 (NA). WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT FELT VIBRATIONS FROM THE FRONT TIRES. THE CONTACT NOTICED THAT THE TREAD FROM THE FRONT PASSENGER SIDE TIRE WAS SEPARATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED…
Source: NHTSA recall and complaint data, updated October 27, 2026. Latest complaint received September 6, 2018.